Suspension complaints by model year
Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
What owners report
Purchased this vehicle new from Tesla on March 29, 2024. As I got home I hear a pop sound come from underneath the car and the abs warning light came on. The vehicle lost some of the functions like regenerative breaking and cruise control. The suspension was also inoperable. I brought the car in on the first availible service date to get the repair done which took a few days. After repair was completed I went back to pick the car up only to have the same warnings appear on the odometer and lost of functionality again 20 minutes into driving home. I contacted Tesla and they gave me another appointment at a different service center. I then brought the car to the other service center and they corrected the ABS and other warning light issue. However, I been experiencing vibration on highways when breaking and regenerative breaking. Since the beginning of ownership. …
The vehicle experienced serious drive control failures on three separate dates: September 21, 2024; October 2, 2024; and July 26, 2025. On each occasion, acceleration was either severely delayed or completely unresponsive, and the vehicle rolled backward when attempting to move forward on an incline. The following warnings appeared on the dashboard: "Stability Control Disabled," ESC (Electronic Stability Control) warning light, and Air Suspension System warning. These symptoms occurred both while stationary and while driving. The vehicle was brought to Tesla service centers twice-on October 10, 2024, and September 2, 2025. On both occasions, Tesla stated that the issue could not be reproduced and returned the vehicle without performing any repairs. During the second visit, Tesla performed a $275 wheel alignment adjustment. …
The contact owns a 2023 Tesla Model X. The contact stated that while his wife was driving 65 MPH with Full Self-Driving mode activated, the rear passenger's side tire exploded. The message "Loss Pressure Rear Tire" was displayed. The contact's wife nearly lost control of the vehicle but was able to drive slowly to the residence. The contact took the rear passenger's side tire to a tire retailer to be replaced. The vehicle was then taken to the tire retailer, where the contact was informed that the vehicle was too heavy for the tires, which caused the tires to warp. All four tires were replaced, and a rear suspension alignment was performed. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 48,000.
The horn button on this steering wheel is so dangerous. I got hit by a car today because it took me too long to find the horn button instead of being able to hit the middle of steering wheel like every other car in the world. Please ask Tesla to fix this.
I continue to experience accelerated severe rear tire wear since my original purchase of this car new in February 2022 on both rear tires (275/45R20). The car has had the alignment specifications confirmed by Tesla. Yet I have had to replace two sets of rear tires in less than 36,000 miles due to the inside edge of both tires being worn through the rubber and into the steel cords of the tires. This last set of tires went ~14,000 miles and still had 5/32" tread depth remaining across all treads. This substantial wear is not readily observed by the vehicle operator without crawling under the car. The wear on these tires is indicative of excessive negative camber settings of the suspension. However, TESLA states the rear suspension alignment is within camber specifications at -2.13 to -2.06 degrees. The tires appear road worthy during a casual walk around of the vehicle. …
I sometimes hear a creaking noise from under my car when driving and steering at low speed and believe there is a potential defect that poses a risk to motor vehicle safety. I took my car into Tesla but they said they would not look at the car unless they could first hear a noise which is I told them is intermittent. They could nto hear a noise at the time, so did nto look at it. I have on occasion heard the noise again. My car is a year old and had around 5.1k miles when I took it in. It now has around 7,500 miles. I have never had a dealer refuse to put the car on a lift, especially a new car that is under warranty, to examine it based on a complaint from a customer. …
On 10-16-21 Saturday around 7:40 PM, I was going to my brother-in-law's house which is on the left side of the road I was driving. It is a single lane road in a busy residential area. I wanted to park outside of the house by the road. I took a left turn towards the gate, then slight reverse and put in drive to pull to park parallel to the road. My Tesla Model-x went into 'Sudden Unintended Acceleration' mode, went left to right to left in a violent way, picking up speed like a rocket. I applied the breaks repeatedly, but the car did not stop and continued to race on the road for about 0.3 mile where the road takes slight left turn. It went and crashed into a 40 ft tall big pine tree at probably more than 150 mph. It knocked off part of the compound wall of the owner, and passenger front tire blew away and landed in their front yard. I had the seat belt on. No other vehicle involved. …
Summary: The front suspension defect on my 2021 Model X, confirmed by St. Petersburg Service Center (Invoice #3000S0013156326), presents a serious safety hazard. Timeline & Concern: Reported Dec 4, 2024, under ESA. Example of Tesla's delay tactics-service was scheduled only after warranty lapsed. Issue diagnosed in May 2025 as a faulty front upper control arm. Safety risk: Failure could lead to loss of control. I request a safety investigation to prevent similar unsafe compromises.
NHTSA investigations
Fore Link Failure
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on forty-three complaints alleging failure of the left or right front suspension fore links in Tesla model year (MY) 2015 through 2017 Model S and MY 2016 through 2017 Model X vehicles.
Frequently asked questions
Which Tesla Model X years have suspension problems?
By NHTSA complaints, the 2016 (151), 2017 (59), 2018 (37), 2020 (37) and 2019 (26) model years. Suspension complaints make up 34% of all complaints for the 2016.
Is there a recall for Tesla Model X suspension problems?
No. NHTSA lists no suspension recall for any Tesla Model X model year. A widespread problem may still be covered by an extended warranty or a manufacturer service bulletin, so ask a dealer.
At what mileage do Tesla Model X suspension problems start?
Across all years, half of the complaints with a recorded mileage happened before about 18,000 miles; 83% happened before 50,000 miles.
What part fails most often?
Owners most often name the front › control arm › upper arm (1 mentions), followed by the front › control arm (1).
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.