Fuel System complaints by model year
Mileage when the problem started
What owners report
I sent following to Tesla I had an accident at around 6:30 PM on Sunday, March 2nd with my Tesla Model 3 and asking to see if you can conduct a diagnostic check into this incident. I was coming home at that time with the Tesla and about 100 yards from my house, I experienced a sudden acceleration with the car going from about 20mph to, I think, over 40 mph and crashed into the garage area of my house. Around the time I started experiencing that unwanted acceleration, I heard a whining sound. As it started that sudden acceleration, I checked below to make sure my right foot was pressing on the brake pedal and it was. Since I have the regenerative braking with my tesla, the car should have decelerated but, instead, it sped up. I continued to press the brake pedal but I could not mitigate my car's continual acceleration. …
After the High Voltage Battery Contactor recall service, my 2025 Tesla Model 3 Performance suffered a sudden 13% drop in range (from 303mi to 264mi at 100% charge). An official Tesla Battery Health Test confirms the battery health is at 92% in less than a year of ownership. This degradation happened immediately following the recall procedure, indicating a hardware or software defect caused by the service.
The rear motor failed on my car. It has less than 4,000 miles on it. It is already being worked on. The car barely gave me 10 seconds before it lost power, locked up and wouldn't move. Yes. They told me the rear motor failed and needed to be replaced. Tesla inspected it themselves and confirmed the issue. Yes, they appeared 10 seconds before it died, I had no other warnings prior to that. This was extremely dangerous as I barely had time to get to a safe place.
Specifically when in somewhat cool and cold temperatures the Front Drive Unit is emitting abnormal high pitched sound that is intermittent at times and that is causing a distraction while driving and is very bothersome. Tesla acknowledged they hear it but nothing is being done about. Front Drive Unit should be replaced.
While crossing the rump and side walk to garage the car, as usual slowly proceed to enter the Garage but immediately the car went into extremely fast speed by itself and hit the side of the Garage, damaged the Garage wall, The garage opener, the cabinet, then hit the water softener and our other car in the front. It also smashed the bike against the wall , damaged the side wall cause a bulge to outside of the structure. The garage frame and right side of the Garage door fell on top of the car almost killed our daughter who was at the front passenger seat. The car brake did not stop the car, the alarm did not go off, the air bags did no inflate.
Car accelerated forward unexpectedly while making a turn and hit a telephone pole. Brakes did not engage nor did the forward collision warning sound or engage. Was manually driving. Car is non-driveable and repairs from Tesla are backlogged so we waiting 8+ weeks to get our car back.
My wife driving our Tesla Model 3. From her report, the car was accelerating on its own and would not stop despite her pressing on the brake pedal. She was unable to stop at the traffic light and crashed into another car at an intersection.
I was manually driving my Tesla Model 3 on the interstate when without warning the car stopped in the middle of the interstate. The entire car locked up and I was unable to turn the wheel or even get it back into gear. I even tried to put on the hazards but the car just completely died. When the vehicle stopped it was at 60% charge on the battery. I sat in panic thinking I was going to get rear ended by the highway traffic. I called for police to come out and cut off traffic. They also had a tow truck company come and tow the vehicle to a local Tesla service center. This was a very dangerous incident because the normally on the interstate vehicles travel at high speeds. I was fortunate that it was rush hour traffic so cars were moving slower than usual and the car behind me was not following closely on my bumper. …
Frequently asked questions
Which Tesla Model 3 years have fuel system problems?
By NHTSA complaints, the 2018 (24), 2021 (10), 2022 (9), 2019 (8) and 2023 (8) model years. Fuel System complaints make up 2% of all complaints for the 2018.
Is there a recall for Tesla Model 3 fuel system problems?
No. NHTSA lists no fuel & propulsion system recall for any Tesla Model 3 model year. A widespread problem may still be covered by an extended warranty or a manufacturer service bulletin, so ask a dealer.
At what mileage do Tesla Model 3 fuel system problems start?
Across all years, half of the complaints with a recorded mileage happened before about 8,000 miles; 100% happened before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.