Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Tesla Model 3 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2020 Tesla Model 3. The contact stated while pulling into the driveway and depressing the brake pedal, the vehicle failed to respond, accelerated unintendedly, broke through the garage door, and crashed into the vehicle parked inside the garage. The other vehicle moved away and damaged the garage. There was no warning light illuminated. The air bags did not deploy. The contact shifted into reverse (R), pulled out of the driveway and shifted into drive (D). The brake pedal was depressed but the vehicle failed to respond. The contact stated that he hit the curb to stop the vehicle, and the vehicle stopped. The contact stated that all the air bags then deployed. The vehicle failed to unlock. The contact rolled down the windows and cried for help until the neighbors arrived and opened the vehicle from the outside. …
The complaint was filed on behalf of the contact's daughter. The contact's daughter owned a 2020 Tesla Model 3. The contact stated that while the contact's daughter was driving at 35 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the contact's daughter stated that the brake pedal felt spongy and unusual. The contact's daughter stated that the brake pedal was depressed to the floor; however, the vehicle still did not stop. The contact's daughter enabled the emergency braking system; however, the vehicle still did not stop. The contact's daughter beeped the horn to alert the nearby driver, and the dash cam independently activated. The contact stated that because of the failure, the contact's daughter's vehicle rear-ended the vehicle in front of the contact's daughter's vehicle. The air bags did not deploy. …
The contact owned a 2020 Tesla Model 3. The contact stated that while driving 50 MPH in traffic on a sunny day, the vehicle drove over a pothole, and the traction control and ABS warning lights illuminated. The brake pedal was checked; however, fifteen minutes later the vehicle crashed into a 26-foot box truck. The contact stated that the box truck left the scene of the crash. The tire skid marks were 100 feet long. The air bags failed to deploy. The contact stated there was an electrical failure which caused the brakes to become inoperable. Additionally, the alerts were late. The contact stated that the battery might need to be replaced. The driver and his daughter, who was seated inside the vehicle, sustained back pain, whiplash, and knee injuries. The driver was transported by ambulance. Medical attention was provided. The contact stated that surgery might be needed in the future. …
on July 19,2022, when I was driving on driveway, at less than 5 miles, I tried to stop to drop my wife and applied brake. Instead of brake, due to computer mal function, it accelerated & hit the garage door, broke the garage door, door fell on the car parked in the garage, damaged that car,and tesla automatically reversed. while reversing brake wasn't working too so I tried to put in drive & brake still was not working so to stop the car for safety, I hit the curb in my front yard All airbags were deloyed, inuring both of us. All doors were locked & we couldn't open any of them. We could open windshield. We shouted HELP and my neighbor came & open the door from outside so we could get out otherwise we both could be dead inside the car
My car did a Phantom break while I was driving on President George bush Turnpike E at the Dallas North tollway exit . I was taking the exit with in the speed limit of 40 miles per hour and was keeping the distance from the car in front. Suddenly the car did an automatic break and car slow down significantly. I got hit from behind and had damage to the bumper and trunk. Emergency break feature went out and an alert came. It is very concerning that the car stops in the middle of road by itself and being hit from behind. I would like an answer from Tesla. I have the dash cam footage of the accident
There are two problems: (1) braking and (2) windshield wiper operation. (1) Braking: When driving on a highway and going by an on-ramp on the right side, without any warning, the vehicle would, al of a sudden, slam violently on the brakes, even though the cars entering the highway are nowhere near where I would be driving. This has happened repeatedly to me, creating a hazard of a rear-end collision. The Tesla Model 3 in such cases would already be in a mode that would drive itself (by me having clicked on the right stalk twice). Additionally, the car often misreads a traffic sign for a different part of the road, such as a stop sign for a side road. The violent braking would take place in such a scenario also. (2) Windshield wiper operation: I'm not sure if this would qualify as a safety issue, but the windshield wiper operation doesn't work in automatic mode. …
Braking and Stopping - Braking system - Improperly functioning braking systems. I experienced a problem with the brake pedal, brake calipers, and/or any component of a Model 3 braking system. "Model 3 has an anti-lock braking system (ABS) that prevents the wheels from locking when you apply maximum brake pressure. This improves steering control during heavy braking in most road conditions...Forward Collision Warning and Automatic Emergency Braking do not operate when driving at very low speeds (see Collision Avoidance Assist on page 128). Do not rely on these features to warn you, or to prevent or reduce-the impact of a collision. (Tesla owners Manuel71-73) I stop on a downward slope with my foot on the brake to wait for a gate to open in my apartments. I let go of the brake and the vehicle remained steady until it started rolling. …
On July 11 at approximately 6:47 a.m., I was operating my Tesla Model 3 on Interstate 65 in Hart County, Kentucky, with Full Self-Driving (FSD) engaged during normal highway travel. Approximately one hour earlier, I had departed a highway rest area after sleeping from the previous day's travel. Rain developed during the trip, but I observed adequate visibility, apparent roadway traction, and I was not impaired. I was traveling in the far-right lane of a three-lane interstate. The posted speed limit was approximately 70 mph; however, FSD limited the vehicle to approximately 65 mph and displayed warnings indicating that the higher speed was unavailable. While FSD remained engaged, the system initiated a lane change from the far-right lane into the center lane. After entering the center lane, the vehicle began displaying repeated warning messages and FSD disengaged multiple times. …
This happened on 2/18/2023. After I charged my car at a local supercharging station, I drove on the local roads for about 2 miles when the car started shutting down. I could barely steer, and the computer monitor stated that the brakes were turning off, and other parts, like cameras, were losing functionality. I pulled over into the local park. I was frightened that my car was no longer functional and that I could be in grave danger driving again. I tried to call Tesla but no one answered. I had to go through the app. My dad came and we found a Youtube video that said to walk out of the car to let it restart. Looks like it happened to another owner. We did that and the car started functioning again. Not sure why it did this after a charge. But it happened again 3 mos later when I was on the freeway. Luckily, I knew what to do from prior experience. …
I was driving on a deserted highway on Interstate 395 heading from LA to Mammoth Lakes. There were no cars behind or in front of us. I first put the Tesla into Auto Steering mode, and things were fine for a while. Then I experienced "phantom braking" with no warning. The car started to brake on its own, and then I disengaged auto steer and drove manually. About 30 minutes later, I put the car into simple "cruise control" and things were fine for a while. Then again with no warning, the car started to hit the brakes. I disengaged the cruise control and took over again. In both cases, there was nothing around us. The weather was clear and sunny. This shouldn't be happening. There was a recent Tesla software update where Tesla apparently discontinued its use of 'radar" for the auto steer and is only relying on the car's cameras. …
Related recalls
Service brakes, hydraulic › Critical fasteners
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021.
Brake complaints in other Model 3 years
Frequently asked questions
How common are brake problems on the 2020 Tesla Model 3?
NHTSA has 48 complaints about the brakes of the 2020 Tesla Model 3, 11% of the model year's 452 complaints.
Is there a recall for 2020 Tesla Model 3 brake problems?
Yes — NHTSA recall 21V-387 (critical fasteners, May 25, 2021). Recall repairs are free at authorized dealers.
At what mileage do 2020 Tesla Model 3 brake problems start?
Half of the complaints with a recorded mileage happened before about 2,000 miles, and 80% before 25,000 miles.
Is it dangerous?
Owners linked 9 crashes, 1 fire and 7 injuries to brakes problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.