Most common 2007 Saturn Ion problems
Share of the 876 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Saturn Ion complaints by model year
Best Ion years: 2005, 2003. Years to avoid: 2006. Compare all years →
2007 Saturn Ion recalls (5)
Electrical system › Ignition
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the…
Steering › Electric power assist system
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014.
Air bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect.
Fuel system, gasoline › Delivery › Fuel pump
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California,…
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012.
Fuel system, gasoline › Delivery › Fuel pump
General motors is recalling certain model year 2006 Chevrolet cobalt and Saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 Chevrolet cobalt, Pontiac g5 and Saturn ion vehicles originally sold in or currently registered in the states of arizona, california,…
Remedy: Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii,…
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2007 Saturn Ion:
Electric Power Steering Failure
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash.
Electric Power Steering Failure
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall…
What 2007 Saturn Ion owners say
Steering all 408 →
The contact owns a 2007 Saturn Ion. The contact stated that while driving at an undisclosed speed, the steering column became inoperable, and the steering wheel locked up. The contact stated that the power steering warning light was illuminated. The contact stopped the vehicle and turned the vehicle off. The contact stated restarted the vehicle and was able to safely drive to her destination. The contact stated that the failure had occurred twice within six months. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
While driving the car has issues with power steering when turning the wheel either direction the steering will lose power steering and jerk the opposite direction turning. I have almost been in numerous accidents now the worst going 75 on highway passing semi around a corner and it jerked and almost sent me right not the semi. This has happened numerous times as I was passing vehicles. Its not a steady no power steering it will do it out of the blue and anymore it's more times than not and again only when turning the wheel. It's scary. Our vin # isn't specified with the recall but has serious power steering issue. No warning lamps or anything like that. We have not had this vehicle inspected yet by a dealership. As far as the incident date it's not one specific date. It does this every day the car is driven.
Electrical system all 215 →
The contact owns a 2007 Saturn Ion. The contact stated that the key would remain stuck in the ignition after turning off the vehicle. The contact stated that the failure had occurred prior and was repaired under NHTSA Campaign Number: 14V171000 (Electrical System). The manufacturer was notified of the failure and reached out to the dealer that performed the recall and confirmed the date that the recall was serviced. The contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was unknown.
My gas tank is leaking a good amount of gas and is dripping all over my exhaust. Major fire risk and also my wiring has been all messed up. When my brights are on, my speakers make an unbearable screaming noise and I saw that this was an issue for many saturn ion users. There was a recall on this car for the same gas tank/pump issue years ago. Can I get this issue fixed free of charge or has the recall expired?
Fuel & propulsion system all 208 →
The contact owns a 2007 Saturn Ion. The contact stated that while he was attempting to start the vehicle failed to start. The contact stated no warning light was illuminated. The contact stated he began to smell a fuel odor inside and outside the vehicle and also saw a fuel leak between the rear tires. The contact took the vehicle to an independent mechanic and was informed that the fuel pump module needed to be replaced. The contact called and made the local dealer aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 12V459000 (Fuel system, Gasoline) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 80,000.
The contact owns a 2007 Saturn Ion. The contact stated while starting the vehicle, there was an abnormal fuel odor entering the cabin of the vehicle. The contact then noticed fuel leaking from the vehicle. The vehicle was not taken to be diagnosed or repaired. The dealer was not contacted. The manufacturer was contacted and stated that the vehicle was not included in NHTSA Campaign Number: 12V459000 (Fuel System, Gasoline). The approximate failure mileage was 76,000.
2007 Saturn Ion engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.2L 4-cyl | 5-speed manual | FWD | 23 / 32 / 26 |
| 2.4L 4-cyl | 5-speed manual | FWD | 22 / 31 / 25 |
| 2.4L 4-cyl | 4-speed automatic | FWD | 21 / 29 / 24 |
| 2.2L 4-cyl | 4-speed automatic | FWD | 21 / 29 / 24 |
| 2.0L 4-cyl supercharged | 5-speed manual | FWD | 20 / 28 / 23 |
EPA ratings. Class: Compact car.
Frequently asked questions
Is the 2007 Saturn Ion a good car?
Based on 876 owner complaints filed with NHTSA, the 2007 Ion rates average: 1.4× as many complaints as a typical year of the Ion at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2007 Saturn Ion?
The steering — 408 complaints, 47% of all complaints for this model year, most often about electric power assist system. Next are the electrical system (215) and fuel & propulsion system (208).
How many recalls does the 2007 Saturn Ion have?
There are 5 recalls for the 2007 Saturn Ion, the most recent from April 10, 2014 (ignition). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Saturn Ion?
The best years by complaints, compared at the same age, are 2005 and 2003. Years to avoid or approach with caution: 2006. See the full Saturn Ion years comparison.
At what mileage do 2007 Saturn Ion problems happen?
The median mileage reported in complaints is about 67,000 miles; 30% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.