Most common 2006 Saturn Ion problems
Share of the 1,235 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Saturn Ion complaints by model year
Best Ion years: 2005, 2003. Years to avoid: 2006. Compare all years →
2006 Saturn Ion recalls (4)
Electrical system › Ignition
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the…
Steering › Electric power assist system
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014.
Air bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect.
Fuel system, gasoline › Delivery › Fuel pump
General motors is recalling certain model year 2006 Chevrolet cobalt and Saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 Chevrolet cobalt, Pontiac g5 and Saturn ion vehicles originally sold in or currently registered in the states of arizona, california,…
Remedy: Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii,…
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2006 Saturn Ion:
Electric Power Steering Failure
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash.
Electric Power Steering Failure
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall…
What 2006 Saturn Ion owners say
Steering all 544 →
The contact owns a 2006 Saturn Ion. The contact stated that the instrument panel and radio were intermittently inoperable. The contact stated that the ignition switch failed to turn to the OFF position as needed intermittently. Additionally, the contact stated that while driving and turning the steering wheel to the right to make a right turn, the steering was significantly wobbly. The contact related the failure to NHTSA Campaign Numbers: 14V171000 (Electrical System) and 14V153000 (Steering). Additionally, the contact stated that the vehicle was experiencing a fuel leak. The vehicle was taken to the Subaru dealer, where it was purchased. The vehicle was not diagnosed or repaired. An unknown Chevrolet dealer was contacted and confirmed that the VIN was not included in a recall. …
The contact owns a 2006 Saturn Ion. The contact stated while exiting a driveway and making a turn, the steering wheel became difficult to turn. There was no warning light illuminated. The contact checked the power steering fluid reservoir and there was power steering fluid in the reservoir. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 90,000.
Electrical system all 392 →
The contact owned a 2006 Saturn Ion. The contact stated while driving at 50 mph and there was a stopped vehicle in the middle of the road, in order to avoid crashing the contact veered to the right lane but crashed into the rear of a truck. The air bags failed to deploy. A police report was not filed. The contact sustained neck, shoulder, arm, and chest injuries that required medical attention. The vehicle was not drivable and was towed to an impound lot. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact was relating the failure to NHTSA campaign number: 14V047000 (Air bags, Electrical system). The manufacturer had been informed of the failure and informed the contact to file for the class action lawsuit. The failure mileage was 90,000.
The contact owns a 2006 Saturn Ion. The contact stated that the instrument panel and radio were intermittently inoperable. The contact stated that the ignition switch failed to turn to the OFF position as needed intermittently. Additionally, the contact stated that while driving and turning the steering wheel to the right to make a right turn, the steering was significantly wobbly. The contact related the failure to NHTSA Campaign Numbers: 14V171000 (Electrical System) and 14V153000 (Steering). Additionally, the contact stated that the vehicle was experiencing a fuel leak. The vehicle was taken to the Subaru dealer, where it was purchased. The vehicle was not diagnosed or repaired. An unknown Chevrolet dealer was contacted and confirmed that the VIN was not included in a recall. …
Fuel & propulsion system all 238 →
The year, make, and model of my car has a factory recall for the fuel pump failing. I went to the dealership and they informed me my Vin # wasn't included and their was nothing they could do about it. My vehicle started leaking fuel last week so I dropped the tank and removed the fuel pump. I have done my homework on this including watching several videos on YouTube concerning this issue and I'm 100% positive this fuel pump has failed in the exact location that all the other recalls have and yet my Vin number isn't on the recall according to this GMC service department manager. I am going to have to put a fuel pump in at my expense today because it's my transportation for work but I'm very upset about this situation and GMCs failure to have my vehicle included and having to replace their defected fuel pump. …
The contact's mother owns a 2006 Saturn Ion. The contact stated that after driving the vehicle to his residence and parking the vehicle in the garage, he observed that a puddle of gasoline had accumulated overnight underneath the vehicle from the fuel tank by the driver's side rear wheel. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The contact stated that the failure might be related to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline). The manufacturer had been informed of the failure. The failure mileage was approximately 84,000.
2006 Saturn Ion engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.2L 4-cyl | 5-speed manual | FWD | 23 / 32 / 26 |
| 2.4L 4-cyl | 5-speed manual | FWD | 22 / 31 / 25 |
| 2.2L 4-cyl | 4-speed automatic | FWD | 21 / 29 / 24 |
| 2.4L 4-cyl | 4-speed automatic | FWD | 21 / 29 / 24 |
| 2.0L 4-cyl supercharged | 5-speed manual | FWD | 20 / 27 / 23 |
EPA ratings. Class: Compact car.
Frequently asked questions
Is the 2006 Saturn Ion a good car?
Based on 1,235 owner complaints filed with NHTSA, the 2006 Ion rates use caution: 2.0× as many complaints as a typical year of the Ion at the same age. It is one of the Ion years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2006 Saturn Ion?
The steering — 544 complaints, 44% of all complaints for this model year, most often about electric power assist system. Next are the electrical system (392) and fuel & propulsion system (238).
How many recalls does the 2006 Saturn Ion have?
There are 4 recalls for the 2006 Saturn Ion, the most recent from April 10, 2014 (ignition). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Saturn Ion?
The best years by complaints, compared at the same age, are 2005 and 2003. Years to avoid or approach with caution: 2006. See the full Saturn Ion years comparison.
At what mileage do 2006 Saturn Ion problems happen?
The median mileage reported in complaints is about 67,000 miles; 28% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.