Most common 2009 Mercury Milan problems
Share of the 226 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Mercury Milan complaints by model year
Best Milan years: 2006, 2007. Years to avoid: 2010. Compare all years →
2009 Mercury Milan recalls (6)
Air bags › Frontal › Driver side › Inflator module
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge.
Air bags › Frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021.
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap.
Air bags › Frontal › Passenger side › Inflator module
Ford Motor Company (Ford) is recalling certain 2013 Ford Mustang vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge.
Air bags › Frontal › Passenger side › Inflator module
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge.
Air bags › Frontal › Passenger side › Inflator module
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California,…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2009 Mercury Milan:
Extended Braking Distance
On December 20, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 16-017 to investigate reports of braking concerns in model year 2007 through 2009 Ford Fusion and Mercury Milan vehicles.Complainants report that after an ABS braking event (caused by braking on a slippery or uneven surface) the brake pedal moved towards the floor and the distance in which the vehicle stopped increased…
Accel Pedal Interference - Acc Floormat
Unsecured mats may interfere with accelerator pedal return to idle. A heel blocker in the floor pan provides a platform that may lift an unsecured mat into contact with the pedal. Ford introduced new pedals as a running change early in model year (MY) 2010 vehicles. Analysis of complaints received by ODI and Ford show elevated rates of pedal entrapment incidents in MY 2008 through early 2010 production vehicles.
Extended Braking Distance
On April 18, 2018, the Office of Defects Investigation (ODI) opened Engineering Analysis (EA) 18-002 to investigate reports of braking concerns in model year (MY) 2006-12 Ford Fusion and Lincoln MKZ, and MY 2006-11 Mercury Milan vehicles manufactured with Continental Automotive System?s ABS hydraulic control units (HCUs).
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined…
What 2009 Mercury Milan owners say
Brakes all 115 →
The contact owns a 2009 Mercury Milan. The contact received notification of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The contact stated that prior to the recall repair, the ABS warning light would appear intermittently. After the recall repair, the ABS warning light was illuminated continuously. The vehicle was taken to the dealer for the recall repair and the Hydraulic Control Unit (HCU) was tested as part of the recall repair, which it failed. The dealer informed the manufacturer of the failure however, the manufacturer declined the coverage for the HCU part replacement. The vehicle was not repaired and the dealer informed the contact that the vehicle was safe to drive with the ABS warning light illuminated. The failure mileage was 189,000.
The contact owns a 2009 Mercury Milan. The contact stated while driving at an undisclosed speed, the brake pedal was depressed and traveled to the floorboard. There was no warning light illuminated. The contact engaged the parking brake to stop the vehicle. The vehicle was restarted. The vehicle was taken to the dealer where it was diagnosed and determined that the ABS hydraulic control unit had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The approximate failure mileage was 100,000.
Air bags all 85 →
Tl* the contact owns a 2009 Mercury Milan. While driving approximately 30 MPH, the brake pedal traveled to the floor when depressed. The contact rear ended the preceding vehicle. There were no warning indicators illuminated. The air bags did not deploy. A police report was not filed and there were no injuries. The vehicle was damaged, but drivable. Meanwhile, the contact reported that there was an open investigation (pe16017) on brake issues related to the year, make, and model vehicle. Also, the contact received notification of NHTSA campaign number: 17V024000 (air bags). The failure mileage was approximately 130,000. VIN tool confirms parts not available.
There is a recall on my Mercury Milan 2009. Last October September October I took my car to hoffman Ford for the replacement of the recall on the airbags. Afterwards I noticed that there was a raising of the dashboard where they replace the airbag. I bought it to their attention, and they said it was from the glue that was used. Later a few months later I noticed the airbag area was expanding and foam was coming through the airbag area & vents over the.consul.I called Ford manf to report this issue. They said to someone will give me a call back ,I never got a call back. Also after the replacement of the airbags there was an issue with my brakes.they told me because of the car setting that is probably just rusty, but I wasn't comfortable and I called them and told them that I was going to bring the car to them and look at it again because something was definitely wrong. …
Speed control & acceleration
I was driving up the hill & slowed down for the speedbump. I started applying the brakes to turn right into the driveway but the car lunged forward, causing me to miss the driveway & turn into the yard. As I stepped on the brake the car continued to speed up so I screamed at my husband "james I can't stop the car!" he yanked the handbrake up but it didn't stop or slow down and the engine made a continuous high pitched racing sound. We crashed into the house, damaging it & breaking my left arm! The car was totaled. All this occurred in just a matter of seconds. Fortunately our family was in another part of the house and weren't injured.
Tl* the contact owns a 2009 Mercury Milan. The contact stated that he started the ignition and the vehicle independently shifted into reverse. The contact crashed into a boat but was not injured. The failure recurred on a separate occasion, causing the contact to crash into a parked sheriff's vehicle. The contact sustained injuries to the head and fractured teeth. A police report was filed. The manufacturer was not notified of the failure. The vehicle was not repaired. The VIN was not provided. The approximate failure mileage was 18,000.
2009 Mercury Milan engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.3L 4-cyl | 5-speed manual | FWD | 20 / 29 / 23 |
| 2.3L 4-cyl | 5-speed automatic | FWD | 20 / 28 / 23 |
| 3.0L 6-cyl | 6-speed automatic | FWD | 18 / 26 / 21 |
| 3.0L 6-cyl | 6-speed automatic | 4WD/AWD | 17 / 25 / 20 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2009 Mercury Milan a good car?
Based on 226 owner complaints filed with NHTSA, the 2009 Milan rates average: about as many complaints as a typical year of the Milan at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2009 Mercury Milan?
The brakes — 115 complaints, 51% of all complaints for this model year, most often about foundation components › master cylinder. Next are the air bags (85) and speed control & acceleration (10).
How many recalls does the 2009 Mercury Milan have?
There are 6 recalls for the 2009 Mercury Milan, the most recent from March 10, 2021 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Mercury Milan?
The best years by complaints, compared at the same age, are 2006 and 2007. Years to avoid or approach with caution: 2010. See the full Mercury Milan years comparison.
At what mileage do 2009 Mercury Milan problems happen?
The median mileage reported in complaints is about 85,000 miles; 25% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.