Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Mercedes-Benz GLC300 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2020 Mercedes-Benz GLC300. The contact stated that while driving at an undisclosed speed, the engine misfired. In addition, the check engine warning light was illuminated. The contact was turned off and restarted the vehicle. The contact stated that the vehicle drove as needed. The contact stated that the vehicle was taken to an independent mechanic however, the failure was unable to be duplicated. The vehicle was not repaired. The contact stated that the failure occurred intermittently for several months. The vehicle was taken back to the independent mechanic where it was diagnosed with a failed engine vent seat and the engine vent seat needed to be replaced. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. …
The contact's wife owns a 2020 Mercedes-Benz GLC300. The contact stated that while his wife was driving at an undisclosed speed, the vehicle stalled. The vehicle was towed to the dealer and diagnosed with ignition failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure but declined to buy back the vehicle and offered a two-year service plan for a free oil change per year. The failure mileage was approximately 30,000.
The contact owns a 2020 Mercedes-Benz GLC300. The contact stated that while stopped at a red light, the vehicle started shaking and jerking. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the cylinder head needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.
My 2020 Mercedes-Benz GLC 300 experienced a complete engine failure at ~51,000 miles, shortly after a major repair for a known defect. Initially, the vehicle showed a misfire on cylinder #3, which was diagnosed at RBM of Alpharetta as low compression due to valve seat damage, matching MB TSB LI01.30-P-072328. The cylinder head was replaced in Aug 2025. About two months later, while driving under normal conditions, the vehicle made a loud cranking/knocking noise and completely stalled in traffic without any check engine light or warning. This sudden stall posed a serious safety risk. The vehicle was towed to the same dealer, who has now diagnosed the engine as fully seized and recommended a complete engine replacement. I had also completed the 50,000-mile scheduled service at the same dealer shortly before this failure. …
Premature oil pump failure on a 2020 Mercedes-Benz GLC 300 with 71,000 miles. The check engine light illuminated on December 29th, 2025 and with no other warning symptoms. The vehicle has been maintained properly, including regular visits to Mercedes-Benz dealerships. The oil pump is a critical engine component that should not fail at this mileage. It has been recommended to not drive the vehicle without repairing as oil can leak onto a hot engine. This issue has been confirmed by a Mercedes dealer. Mercedes-Benz has offered $1,000 in goodwill on a $7,400 repair, which is unreasonably low given the nature of the failure. The dealer is advocating for higher goodwill, but corporate has refused to escalate or provide a breakdown of the offer. …
The contact's son owns a 2020 Mercedes-Benz GLC300. The contact stated that when the vehicle was taken for the State Emissions Inspection, the vehicle failed the inspection due to a defective "smoke cannister". The contact stated that after the vehicle failed the inspection, the "check emissions" message appeared on the instrument panel. The contact called a dealer and was advised to purchase and install the smoke cannister. The vehicle was taken to an independent mechanic who installed a new smoke canister; however, the failure reoccurred, and the vehicle failed the State Emissions Inspection test again. The vehicle was taken back to the dealer where the vehicle was diagnosed with a defective smoke canister and valve. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was unknown.
My check-engine light recently illuminated, and diagnostic testing identified fault code P06DA00, relating to the oil pump control valve circuit. I have been quoted over $5,000 to replace the oil control valve and oil pump harness. I was quoted the following by Mercedes Servuce in Manchester, NH- Oil Pressure Regulator Valve: need to remove lower oil pan only to access oil control valve and replace the valve and sub harness. $5013.52. This is a known issue. My vehicle has been well maintained, and I have been advised that it is otherwise in excellent mechanical condition. I intend to keep and drive this vehicle for many more years, which makes it particularly disappointing to encounter a repair of this magnitude for a component that is not considered a routine maintenance or wear item.
I have had my car for almost two years. This problem has been on-going the whole time. It happens intermittently, I never know. I will be driving it and usually when I am making a turn or pulling onto a main road, you press the gas to go and the car hesitates and makes a loud brooooooooom sound like it is trying to go or figure out what to do and if you are pulling out onto a main road with on comming traffic, this is dangerous. We have seen information that on the 2019 and 2018 GLC300's this has been documented, my car is a 2020 but it's the same thing. It's like the car hesitates and slows down when it should go!
The engine is failing, I was on my way to drop my [redacted] off at daycare when suddenly my car went above and stayed above 5rpms meanwhile I was only able to drive 8mph. This caused a tractor trailer swerving into on coming traffic, if he didn't my toddler and I would have been killed. As I managed to pull off and call my husband to get the baby the engine started making a strange clicking noise. There's maybe 60,000 miles on this vehicle none of this should be happening.
With approximately 57,500 miles, the car began idling roughly, misfiring and losing power. The dealership has diagnosed it with a cracked cylinder head which will require a replacement at a cost of $9,765.00. The dealership indicated this is a common issue with the M264 engine (rear wheel driver) in the GLC300 and the M260 engine (the front wheel drive version) has already had a service extension for 15 years/180,000 miles. This type of failure should not occur at this mileage or even significantly more.
Related recalls
Engine and engine cooling › Engine › Gasoline › Turbo/supercharger
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2020 C300, E350, and GLC300 vehicles equipped with turbocharged 4-cylinder gasoline engines. The screws that retain the turbocharger oil feed and return lines may not have been properly tightened, possibly resulting in an oil leak.
Remedy: MBUSA will notify owners, and dealers will inspect the turbocharger oil lines and tighten them as necessary, free of charge. The recall began August 17, 2020. Owners may contact MBUSA customer service at 1-800-367-6372.
Engine complaints in other GLC300 years
Frequently asked questions
How common are engine problems on the 2020 Mercedes-Benz GLC300?
NHTSA has 21 complaints about the engine & cooling of the 2020 Mercedes-Benz GLC300, 30% of the model year's 69 complaints.
Is there a recall for 2020 Mercedes-Benz GLC300 engine problems?
Yes — NHTSA recall 20V-364 (turbo/supercharger, Jun 22, 2020). Recall repairs are free at authorized dealers.
At what mileage do 2020 Mercedes-Benz GLC300 engine problems start?
Half of the complaints with a recorded mileage happened before about 30,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.