Most common 2003 Mercedes-Benz E320 problems
Share of the 214 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Mercedes-Benz E320 complaints by model year
Best E320 years: 2008, 2009, 2002. Years to avoid: 2005, 2004, 2003, 1999, 1997. Compare all years →
2003 Mercedes-Benz E320 recalls (2)
Visibility › Sun/moon roof assembly
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372.
Visibility › Sun/moon roof assembly
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2003 Mercedes-Benz E320:
Fuel Leakage From The Fuel Tank
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of…
What 2003 Mercedes-Benz E320 owners say
Fuel & propulsion system all 88 →
The contact owns a 2003 Mercedes-Benz E320. The contact stated that after refueling the vehicle there was an abnormal gasoline odor inside the vehicle. The contact removed the rear seat where the fuel tank was located and discovered that fuel was leaking into the vehicle underneath the rear seat instead of going into the fuel tank. There was no warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 73,000.
The contact owns a 2003 Mercedes-Benz E320. The contact stated that there was an abnormal fuel odor throughout the vehicle. Upon inspection, the contact discovered a fuel leak coming from underneath the vehicle, above the fuel tank. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was 202,800.
Brakes all 77 →
MB USA is not honoring Recall 2005110001 for 25 years per NHTSA Bulletin. The Mercedes Benz Representative said that the recall is closed for a 2003 car, but which should not be closed until 2028 for my car. The Mercedes Benz Representative agreed that she does see the car matches the 2003-2006 E class with chassis of A336226 falling between A0- and A7- for the recall. The Mercedes Benz Representative gave no explanation as to why the 25 year recall has closed prior to 2031. The faulty SBC has caused numerous problems. If the recall is not honored, I plan to file a lawsuit against Mercedes. A formal complaint is being filed with the NHTSA for MB USA's lack of adhering to the recall for the full 25 years.
The contact owns a 2003 Mercedes-Benz E-320. The contact stated while driving 30 MPH, the braking system became inoperable. The contact stated that the ABS warning light was illuminated after the failure. The contact stated that the failure was related to TSB: 2005110001. The contact called the local dealer and was informed that the VIN was not under recall. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who stated that the failure was due to the sensotronic brake control (SBC) braking system. The manufacturer was contacted and the contact was informed that the VIN was not under recall for the failure. The failure mileage was unknown.
Electrical system all 21 →
*1. The Fuel Tank and components and/or system failed or malfunctioned. *2. After filling the gas tank, the odor of strong pungent gasoline fumes fills the cabin of the and lingers for some time in the car and garage until the gasoline level goes down after being driven for a few miles. *3The car has been taken to a certified Mercedes Benz Dealership Service Center and was told that the problem was the gas tank and system/components. *4.The car was inspected by a certified Mercedes Benz Dealership Service Center Mechanic *5. There were NO warning lamps or messages on the dashboard or message center on car. The only symptoms of the problem was the strong odor of gasoline fumes after fuel fill ups.
Everytime I get in my car, the battery is dead! I have purchased several brand new batteries, and the same thing! I purchased a new battery, and my wife and I went on vacation, and as we was headed back home, we began to smell a real foul oder! We stop to the gas station, and looked everywhere, but didn't see anything! As we continue to drive, and turned in the drive way the battery light came on! I opened the trunk, and there was the foul smell, and the battery was so hot it could have caught fire, luckily we was home
2003 Mercedes-Benz E320 engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.2L 6-cyl | 5-speed automatic | RWD | 17 / 24 / 20 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2003 Mercedes-Benz E320 a good car?
Based on 214 owner complaints filed with NHTSA, the 2003 E320 rates avoid: 2.9× as many complaints as a typical year of the E320 at the same age. It is one of the E320 years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2003 Mercedes-Benz E320?
The fuel & propulsion system — 88 complaints, 41% of all complaints for this model year. Next are the brakes (77) and electrical system (21).
How many recalls does the 2003 Mercedes-Benz E320 have?
There are 2 recalls for the 2003 Mercedes-Benz E320, the most recent from November 19, 2024 (sun/moon roof assembly). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Mercedes-Benz E320?
The best years by complaints, compared at the same age, are 2008, 2009 and 2002. Years to avoid or approach with caution: 2005, 2004, 2003, 1999 and 1997. See the full Mercedes-Benz E320 years comparison.
At what mileage do 2003 Mercedes-Benz E320 problems happen?
The median mileage reported in complaints is about 100,000 miles; 14% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.