Most common 2005 Mazda B-Series Truck problems
Share of the 16 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Mazda B-Series Truck complaints by model year
Best B-Series Truck years: 2005, 2007, 2006. Years to avoid: 1999, 2000, 1996, 1998, 1997. Compare all years →
2005 Mazda B-Series Truck recalls (3)
Air bags › Frontal › Passenger side › Inflator module
Mazda North American Operations (Mazda) is recalling certain 2004-2006 B-Series vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement front passenger air bag inflators may have been installed incorrectly.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed February 1, 2024.
Air bags › Frontal › Passenger side › Inflator module
Mazda North American Operations (Mazda) is recalling certain 2004-2006 Mazda B-series trucks. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Mazda will notify owners, and dealers will replace the passenger side frontal air bag inflator with an alternate inflator, free of…
Air bags › Frontal › Driver side › Inflator module
Mazda North American Operations (Mazda) is recalling certain 2004-2006 B-Series trucks. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Remedy: Owners are advise not to drive their vehicles until the repair has been performed. Mazda will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2005 Mazda B-Series Truck:
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag…
Brake lights inoperative
This pe was opened based on technical service bulletin (TSB) #05-6-19 issued by Ford motor company and service bulletin #09-008/5 issued by Mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing.
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag…
What 2005 Mazda B-Series Truck owners say
Air bags
The contact owns a 2005 Mazda B-Series ZJ57. The contact received notification of NHTSA Campaign Numbers: 17V806000, 17V807000, and 23V837000 (Air Bags) however, the dealer had refused to complete the recall due to the air bags that had inflated during a crash. The contact stated that the manufacturer refused to honor the recall repair. The manufacturer was made aware of the issue. The contact had experienced a failure. The contact stated while driving at approximately 20 MPH and as he was turning to the left, he did not observe that another vehicle was crossing his path. The contact stated that his front driver's side bumper, headlight, and grill crashed into the front passenger door of the vehicle. The contact stated that the driver's side and passenger front air bags deployed. …
Tl* Takata recall. The contact owns a 2005 Mazda b-Series Truck. The contact received notification of NHTSA campaign number: 17V806000 (air bags); however, the parts to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer (jim click Mazda auto mall tucson, 700 w auto mall dr, tucson, az 85705, [phone]) was contacted and confirmed that the parts were not available for the recall remedy. The manufacturer was made aware of the issue and was not able to confirm when the parts were to become available. The contact had not experienced a failure. Parts distribution disconnect.
Frequently asked questions
Is the 2005 Mazda B-Series Truck a good car?
Based on 16 owner complaints filed with NHTSA, the 2005 B-Series Truck rates better than average: 93% fewer complaints than a typical year of the B-Series Truck at the same age. It is one of the best B-Series Truck years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2005 Mazda B-Series Truck?
The air bags — 16 complaints, 100% of all complaints for this model year. Next is the lights (1).
How many recalls does the 2005 Mazda B-Series Truck have?
There are 3 recalls for the 2005 Mazda B-Series Truck, the most recent from December 12, 2023 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Mazda B-Series Truck?
The best years by complaints, compared at the same age, are 2005, 2007 and 2006. Years to avoid or approach with caution: 1999, 2000, 1996, 1998 and 1997. See the full Mazda B-Series Truck years comparison.
At what mileage do 2005 Mazda B-Series Truck problems happen?
The median mileage reported in complaints is about 75,000 miles; 0% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.