Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 Kia Sorento owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2012 Kia Sorento. The contact stated that while the vehicle was parked in her carport, she was awakened by her son that a fire had ignited and that the vehicle was in flames. The contact then stated that the fire from the vehicle had extended to her home living room. As a result, half of the house was in flames. The contact stated that she and her family were able to exit her home to safety and then notified the fire department. The fire department had extinguished the fire. No injuries were sustained. No medical attention was required. The family's iguana pet passed away due to the fire. The contact then stated that the vehicle was towed to a tow lot and inspected by the insurance company and that the source of the fire was near the carport area and may have been electrical related but was to be determined. …
The contact owned a 2012 Kia Sorento. The contact stated that the vehicle stalled while driving at approximately 30 MPH as the battery and alternator warning lights illuminated. Another driver then alerted the contact that the vehicle had caught fire under the hood. The contact merged to the side of the road and exited the vehicle. The contact mentioned that a third of the vehicle had been engulfed in flames. The fire department extinguished the fire. The contact sustained injuries to her knee from the door while attempting to exit during the incident. Medical attention was required. The vehicle was towed to an impound lot and deemed totaled by the insurance agency. A fire report was filed but there was no police report filed. The manufacturer was made aware of the failure and opened a case. …
On August 23rd 2024, I drove this vehicle all day. But, upon reaching our final destination (ER department entrance) smoke began rolling out from under the hood. Once getting out to inspection the vehicle someone hollered for a extinguisher. I turned to look at the vehicle and I could see underneath of the 2012 kia sorento had flames. My son was still in the car so my mother and I ran to get him out of his rear facing carseat and ran away from the vehicle. At this time the vehicle still had a fire that went out with extinguisher but quickly light back up. After this the whole are and car filled with smoke. Fire department was called and this took them awhile to fully extinguish the fire. This could have hurt myself, my child, and my mother. I lost alot of valuable things including my son's new carseat, my children's double stroller, a tablet, clothing, etc. …
The contact owns a 2012 Kia Sorento. The contact stated that the alarm continued to engage independently. The contact was able to turn the alarm off. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 110,000. VIN tool confirms parts not available.
The contact owns a 2012 Kia Sorento. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated, prompting the contact to pull the vehicle into a parking lot. The contact also stated that the vehicle history stated that the engine was replaced by the dealer when the vehicle was purchased. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000.
i was out door dashing on monday january 15 2024. i went into panera to pick up order. came outside to my car and it looked like it was smoking. i popped the hood and was about to put my hand in there to lift the hood when i realized it was hot. i looked under and it was on fire.. everything is melted.. there wasnt any warnings at all. now i have know car..
These vehicles were never equipped with an alarm to notify drivers when parked in any other gear other than 'Park'. If the driver parks vehicle in 'Reverse' and do not set the parking brake, he/she can shut off the engine with no alarms notifying the driver to move shifter to park. An incident occurred with this vehicle in which the driver parked it overnight in a parking garage on level 6. The space appeared level, but is on a very slight incline. The vehicle (miraculously) remained in place overnight. However when the same driver proceeded to use the vehicle the following morning, it wouldn't start (obviously because you cannot start these vehicles unless the shifter is in 'Park' or 'Neutral'). He thought the battery was dead, not thinking to check the position of the shifter. After trying to get the vehicle to start with no success, he left the vehicle to use his personal vehicle. …
A notice was mailed to me on [redacted] Recall #[redacted], advising that the hydraulic electronic control unit may experience an electrical short circuit, which can result in engine compartment fire. Park the vehicle outdoors and away from other vehicles or structures until the recall has been performed. The malfunction indicator light appeared approximately a month and a half ago, and I contacted my KIA dealer who advised me that I must have the car towed to their location at my expense They billed me over $200, plus the towing. The recall has still not been addressed. This is an extreme problem for me. I live in Florida and have a very unhealthy relative out of state but feel that it is unsafe to drive my vehicle far from home which has caused me and my family extreme anxiety. I have received no updates from KIA since the initial 11/14/23 letter. …
The Hydraulic Electronic Control Unit (HEUC) may experience an electrical short circuit, which may result in an engine compartment fire while driving or parked. The notice was received 11.14.23. The part is not available. The warning light under the WARNING in the letter, illuminated on my dashboard and I followed the WARNING instructions: PULL OVER TO A SAFE LOCATION. TURN OFF THE ENGINE. CALL KIA ROADSIDE ASSISTANCE AND HAVE THE VEHICLE TOWED TO A KIA DEALER AS SOON AS POSSIBE. I did this. I had to pay $166.77 for the tow and can't be refunded until the remedy notice is issued. Kia tells me they have to charge $190 to diagnose the car and that there is no remedy at this time. It has been 77 days, today, since the recall was sent. I understand Kia is aware prior to the notice issuing. This is a major safety issue. A fire can be catastrophic. This is interfering with my livelihood. …
In 2012 my sister bought new 2012 Kia Sorento from Caribbean Auto Mart in St Thomas VI. About a year ago, the horn stopped working and the air bag light has been on for some time now clearly indicating a possible problem with the clock spring assembly in the steering column mentioned in the recall notice attached. On contacting the dealer, Caribbean Auto Mart, she was told that they were no longer a Kia dealer and that it was not their responsibility to fix the problem. The local Jiffy Lube apparently is doing warranty work for Kia here now but they refuse to fix it without authorization from Kia. On contacting Kia, they refuse to even acknowledge the existence of this vehicle. They say they have no matching VIN. We asked if they would just send the part and I would install it. They refused this as well. …
NHTSA investigations
Non-crash Vehicle Fires
During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optima, MY 2011-2014 Kia Sorento and MY 2010-2015 Kia Soul vehicles equipped with Theta II, Gamma, Nu and Lambda II engines…
Non-crash Vehicle Fires
In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition.
Electrical complaints in other Sorento years
Frequently asked questions
How common are electrical problems on the 2012 Kia Sorento?
NHTSA has 127 complaints about the electrical system of the 2012 Kia Sorento, 14% of the model year's 880 complaints.
Is there a recall for 2012 Kia Sorento electrical problems?
No. NHTSA lists no electrical system recall for the 2012 Kia Sorento, though it has 5 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 Kia Sorento electrical problems start?
Half of the complaints with a recorded mileage happened before about 71,000 miles, and 20% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 20 fires and 6 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.