Which parts fail
Components named in complaints (headlights, tail lights, turn signals, interior lights).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Kia Sorento owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2011 Kia Sorento. The contact stated while driving at night at an undisclosed speed, the contact was noticed while making a slight turn, the driver's and passenger's side headlights stopped functioning as designed. The failure also occurred while using the turn signals. The contact had to manually activate the headlights after the failure. The vehicle was taken to an independent mechanic to be diagnosed however, the mechanic was unable to duplicate the failure or determine the cause of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000. Subsequent to the initial complaint, in December 2021, the car owner, Ed Ruzicka, decided to see if replacing the turn signal/wiper control shaft would fix this problem. I did so at my own expense. The lights no longer blink off. …
Passenger low beam kept burning out. I kept replacing. This morning, on my way home from work (I work nights on an ambulance) I could smell burning, and saw that the light was out once again. Got home, and the entire connector/wiring to the bulb was completely melted and sizzling, with a small flame at the base of the plastic connector. This is outrageous. There were recalls for this EXACT issue for other Sorentos, but mine was not included. This could have started a major vehicle fire, and I cannot afford a vehicle electrician. Kia should be replacing this.
The contact owns a 2011 Kia Sorento. The contact stated that while driving at an undisclosed speed at night, after applying the turn signals, the headlights and instrument panel lights became inoperable. The contact related the failure to the electrical system; however, the vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,000.
The contact owns a 2011 Kia Sorento. The contact stated while driving at nighttime, the front headlights turned off independently. The contact stated no warning light was illuminated. The contact was able to drive to his destination. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 125,000.
I was driving and my Kia started over heating and smoking and smelled like plastic burning I got it towed to the Hendricks of Kia and it sat there for 2weeks and I contacted them about giving me a lender until they fix my engine problem and they told me that my engine is not under warranty but is a recall I didn't blow my engine I recently bought it about 6 months ago
The contact owns a 2011 Kia Sorento. The contact stated that while, driving at an undetermined speed at night and making a turn the headlights became inoperable without warning for a few seconds. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was 120,000. The VIN was not available.
My Kia Sorento 2011 in November 2023 started having the instrument cluster warning lights flashing, abs warning light, tire pressure light and sometimes the check engine light. There is also a very strong burning or melting smell when the car is on. I was very scared to drive my car and have had to find ways to get to work when I received the notice from Kia that there was a recall SC284. About HECU fuse that many Kia Sorento 2011 owners are having issues with the engines catching fire while driving or parked. And the symtoms before a fire occurs are the same as I have experienced with the instrument cluster illuminating and the strong burning smell as well. Its April 2024 and I haven't had a car since November 2023 because the recall has yet to be remedied. …
2011 Kia Sorento headlights come on during the bright part of the day and also turn off while driving at night in the auto mode. It is dangerous to be driving while at night when headlights just go out at any time and all the other inside dash lights go dim. It also happens that the headlights come on during the afternoon when it is bright outside also and causes the inside dash lights to go dim. Have seen several Kia owners complaining about this same issue. Very, very dangerous to drive at night. No warning of this is going to happen. This is putting us and others at risk of a life threatening situation. No dealership or auto repair shop can address the problem unless they are there when it actually happens. It is available for inspection at anytime to fix this problem.
When driving at night my headlights flicker off and on for about 3 seconds, also when I attempt to use my turn signal, the lights will blink out and I have to jiggle the handle to get the lights to come back on. Sometimes when I turn the corner the head lights will blink off and then come back on and this takes about 3 scary seconds. Unable to drive in an unfamiliar or dark area because the lights are subject to go out. There is no warning light, message or other symptom to address the problem. I was told that there might be a recall on this issue. Is there any technical service bulletin addressing this issue. Please advise as this can be a very dangerous situation
What component or system failed or malfunctioned, and is it available for inspection upon request? HEADLIGHTS How was your safety or the safety of others put at risk? THE LIGHTS RANDOMLY SHUT OFF WHILE DRIVING AT NIGHT. Has the problem been reproduced or confirmed by a dealer or independent service center? NO Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO Started a while ago. Haven't driving it since fall.
Related recalls
Exterior lighting › Brake lights › Switch
Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles.
Remedy: Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge.
NHTSA investigations
Headlight Failure
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) based on seventy-four Vehicle Owner Questionnaires (VOQs) reporting headlight failures on model year (MY) 2011-2013 KIA Sorento vehicles.In its response to ODI's June 25, 2020, information request letter (portions of which were submitted under request for confidentiality), Kia Motor America (Kia) provided design details of the…
Headlight complaints in other Sorento years
Frequently asked questions
How common are headlight problems on the 2011 Kia Sorento?
NHTSA has 105 complaints about the lights of the 2011 Kia Sorento, 7% of the model year's 1,520 complaints. The component named most often is headlights (5 mentions).
Is there a recall for 2011 Kia Sorento headlight problems?
Yes — NHTSA recall 13V-114 (switch, Apr 1, 2013). Recall repairs are free at authorized dealers.
At what mileage do 2011 Kia Sorento headlight problems start?
Half of the complaints with a recorded mileage happened before about 96,000 miles, and 5% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 6 fires and 2 injuries to lights problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.