Most common 2022 Kia EV6 problems
Share of the 279 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Kia EV6 complaints by model year
Best EV6 years: 2024. Compare all years →
2022 Kia EV6 recalls (4)
Electrical system › Propulsion system › Traction battery
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge.
Electrical system › Propulsion system › Charging › Module › Software
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge.
Electrical system › 12V/24V/48V battery
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge.
Parking brake › Electrical › Control module › Software
Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Remedy: Drivers are recommended to park their vehicles on level ground and avoid parking on a slope/inclined surface whenever possible until the remedy has been performed.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2022 Kia EV6:
Loss of Motive Power
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
What 2022 Kia EV6 owners say
Electrical system all 212 →
The contact owns a 2022 Kia EV6. The contact stated that while the vehicle was parked on a hill, it rolled and crashed into a handicapped sign. The forward collision sensor became inoperable. While at the charging station utilizing the radio, the battery and collision warning indicator lights were illuminated. The vehicle was taken to the local dealer where they were unable to identify the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted but provided no additional assistance. While driving, an unknown vehicle crashed into the rear of the vehicle and a quarter panel. There was no reported injuries, fire, or police report. The vehicle was taken to another dealer (Kia of Irvine 45 Oldfield, Irvine, CA 92618,) where the vehicle failed to start and it was diagnosed that the battery needed to be replaced. The battery was replaced but the failure persisted. …
The contact owns a 2022 Kia EV6. The contact received notification of NHTSA Campaign Number: 24V867000 (Electrical System) and the vehicle was repaired at the local dealer. The contact stated that four months later while driving 75 MPH, there was a popping sound coming from the rear of the vehicle. The message to "Check Electrical System" was displayed, and the vehicle unexpectedly decelerated to approximately 45 MPH. The contact continued driving and the message to "Stop Vehicle and Check Power Supply" was displayed. The vehicle decelerated to 5 MPH and failed to accelerate as intended. The vehicle was pulled over to the side of the road and inspected. All the doors were unlocked, and the vehicle then stalled. The vehicle failed to restart. …
Fuel & propulsion system all 43 →
After driving my vehicle for a few minutes on my way to work my car lost speed rapidly, going from 40 mph to 25 then seconds later to 22 mph. I tried to accelerate; the car was unresponsive and would not accelerate over 22 mph. Dropping speed rapidly and suddenly during rush hour on a secondary road with a limited shoulder was unnerving as the slow response required waiting for a gap in traffic flow to safely turn around to head home. Upon returning home a message appeared on right side of dash board in an orange circle "check vehicle system" with a small upside down triangle with letters EV also inside this circle and a "small orange battery" picture showed on the left. I called Kia Roadside Assistance and reported the above and was advised it would take about 90 minutes for a tow to dealer as I was unwilling to drive it. …
While driving in a major thoroughfare, a red warning came on to check the electrical system, and that propulsion power may be limited. We pulled over to a parking area and consulted the manual. It suggested turning the engine off and back on again - we did so, but the warning remained. We determined that we were 2-4mi from our Kia dealer. Based on the manual information, we believed we would be able to drive at a slow speed and selected a route towards the dealer that avoided the highway. However then the 'turtle' warning light came on and we we were reduced to walking pace. We pulled into a side road, but were unable to pull over completely before we lost all motion. We activated the warning lights, but after a minute or so there was not even sufficient power for those. This was a rainy day with not great visibility. We feel lucky and this could have been so much more dangerous. …
Transmission & drivetrain all 41 →
The contact owns a 2022 Kia EV6. The contact stated that while the vehicle was parked on a hill, it rolled and crashed into a handicapped sign. The forward collision sensor became inoperable. While at the charging station utilizing the radio, the battery and collision warning indicator lights were illuminated. The vehicle was taken to the local dealer where they were unable to identify the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted but provided no additional assistance. While driving, an unknown vehicle crashed into the rear of the vehicle and a quarter panel. There was no reported injuries, fire, or police report. The vehicle was taken to another dealer (Kia of Irvine 45 Oldfield, Irvine, CA 92618,) where the vehicle failed to start and it was diagnosed that the battery needed to be replaced. The battery was replaced but the failure persisted. …
On April 13, 2024, when I started my vehicle, the instrument cluster immediately flashed the following warning msg surrounded by a flashing red circle: 12V Battery Very Low Stop Safely I turned the vehicle off, waited a few seconds and when I started it again the message did not appear. I contacted KIA USA and received a Recall Inquiry Case #. On April 18th, when I started my vehicle the same 12V Battery Very Low, Stop Safely msg displayed. It did not disappear upon restarting. Within 5 mts ALL the electrics were dead, including the instrument cluster AND the parking/emergency brake control AND the Vehicle Start On/Off button. I am very fortunate I was not driving on the highway when this occurred. Ditto for other drivers. My vehicle had to be towed to my dealer/service center. The tow service jumped the 12V battery and was able to drive it up on the flatbed. …
2022 Kia EV6 engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined | Range |
|---|---|---|---|---|
| Electric | Single-speed | RWD | 134 / 101 / 117 MPGe | 310 mi |
| Electric | Single-speed | AWD | 116 / 94 / 105 MPGe | 274 mi |
EPA ratings. Class: Wagon.
Frequently asked questions
Is the 2022 Kia EV6 a good car?
There isn't enough complaint history for the EV6 to compare model years reliably. So far owners have filed 279 complaints with NHTSA.
What is the most common problem with the 2022 Kia EV6?
The electrical system — 212 complaints, 76% of all complaints for this model year, most often about 12v/24v/48v battery. Next are the fuel & propulsion system (43) and transmission & drivetrain (41).
How many recalls does the 2022 Kia EV6 have?
There are 4 recalls for the 2022 Kia EV6, the most recent from July 2, 2026 (traction battery). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Kia EV6?
The best years by complaints, compared at the same age, are 2024. See the full Kia EV6 years comparison.
At what mileage do 2022 Kia EV6 problems happen?
The median mileage reported in complaints is about 12,000 miles; 75% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.