Most common 2020 Hyundai Sonata problems
Share of the 181 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Sonata complaints by model year
Best Sonata years: 2025, 2019, 2020. Years to avoid: 2011, 2013, 2012, 2015, 2017. Compare all years →
2020 Hyundai Sonata recalls (4)
Fuel system, gasoline
Hyundai Motor America (Hyundai) is recalling certain 2020-2023 Sonata vehicles. A damaged check valve can allow air to enter the fuel tank, causing it to expand and contact hot exhaust components, melting the tank.
Remedy: Dealers will inspect and replace the check valve. The fuel tank assembly will be inspected for damage and replaced if necessary. Additionally, dealers will inspect and update the engine control unit software.
Latches/locks/linkages › Trunk lid › Latch
Hyundai Motor America (Hyundai) is recalling certain 2020 Sonata and Sonata Hybrid, and 2019 Genesis G70 vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside.
Remedy: Dealers will inspect the trunk latch and replace the trunk latch base, as necessary, free of charge. Owner notification letters were mailed May 26, 2022. Owners may contact Hyundai customer service at 1-855-371-9460.
Electrical system › Software
Hyundai Motor America (Hyundai) is recalling certain 2020 Nexo and Sonata vehicles. The Remote Smart Parking Assist (RSPA) software may fail to prevent vehicle movement upon detection of an RSPA system malfunction.
Remedy: Hyundai will notify owners, and dealers will reprogram the RSPA software, free of charge. The recall began June 3, 2020. Owners may contact Hyundai customer service at 1-855-371-9460.
Equipment › Other › Labels
Hyundai Motor America (Hyundai) is recalling certain 2020 Sonata vehicles produced between October 22, 2019 and February 13, 2020. The tire pressure label inside the driver's door and the owner's manual state an incorrect tire size.
Remedy: Hyundai will notify owners, and dealers will install new label stickers over the tire pressure label and in the owner's manual, free of charge. The recall began April 22, 2020.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2020 Hyundai Sonata:
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
What 2020 Hyundai Sonata owners say
Fuel & propulsion system all 59 →
My vehicle was at a manufacturer authorized dealership for a federally mandated recall repair. While the vehicle was in the dealership's exclusive care, custody, and control, it was struck by a third party cleaning vendor operating on dealership property and was declared a total loss. I did not hire or authorize this vendor. After the incident, the manufacturer informed me in writing that the dealership would repair the damage at their own expense, separate from the recall work. The manufacturer also stated they were covering the recall related repairs and were coordinating with the dealership. They provided weekly updates, monitored the recall repair, and escalated a backordered recall part. …
The contact owns a 2020 Hyundai Sonata. The contact stated that while driving at an undisclosed speed with the family inside the vehicle, a strong gasoline odor was inside the cabin of the vehicle. The contact stated that the fuel gauge was lowering quickly. Upon exiting the vehicle, the contact became aware of gasoline gushing heavily out of the vehicle onto the ground. Two months prior to the failure, the vehicle was taken to an authorized dealer due to an abnormal sound coming from the rear of the vehicle. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the recall repair was not performed because the part for the recall repair was not yet available. The vehicle was towed to a dealer where it was determined that the gas valve was not properly fixed. …
Electrical system all 40 →
The contact owns a 2020 Hyundai Sonata. The contact stated that while her husband was driving 75 MPH, the brake warning light appeared on the instrument panel as the vehicle began to hesitate upon depression of the accelerator pedal. The contact stated that the vehicle decelerated to 20 MPH as her husband pulled to the side of the highway and turned off the vehicle. The contact called the dealer and was given suggestions on how to correct the failure; however, none of the options worked. After some time, her husband restarted the vehicle and the vehicle resumed normal operation. The next day, the contact stated that the brake light returned upon start of the vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 19,000.
While stopping at a major highway intersection on [redacted] for a red light vehicle stalls and will not start back up while everyone else continues at a 55 mph mile an hour passing me on each side! This happened more than 6 times . While you're stuck in intersection,you have to keep trying to start the car eventually it will start . Apparently it is EGR valve and is a very common problem. IT IS NOTED IN THE common problem for this year making model and the repair cost is in the range of $1600 even the dealership said it is a very common problem. They have been experiencing it.
Engine & cooling all 32 →
The contact owns a 2020 Hyundai Sonata. The contact stated that the fuel failed to go into the tank. The seat failed to move. The engine light illuminated. The vehicle stalled. While driving, the fuel gauge went from full to empty. The contact received the NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline) after the failure. The vehicle was towed to the local where it was diagnosed that the fuel tank had expanded. The vehicle was repaired approximately eight months later. The contact called another local dealer. Ourisman Hyundai Bowie, 2404 Crain Hwy A, Bowie, MD 20716, who was unable to schedule an appointment. The manufacturer instructed the dealer to keep the vehicle due to it being a fire risk. The manufacturer was contacted regarding a buyback. The failure mileage was approximately 80,000.
The contact owns a 2020 Hyundai Sonata. The contact stated while driving at an undisclosed speed, there was an abnormal gasoline odor inside the vehicle. The contact then heard a loud pop and pulled over to the shoulder of the roadway. After a visual inspection, the contact observed gasoline leaking from the fuel tank filler neck, even though the access door and gas cap were both securely closed. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the canister purge valve, causing the fuel tank to swell, resulting in damages to the fuel pump. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 47,000.
2020 Hyundai Sonata engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.0L 4-cyl hybrid | 6-speed dual-clutch | FWD | 50 / 54 / 52 |
| 2.5L 4-cyl | 8-speed automatic | FWD | 28 / 38 / 32 |
| 1.6L 4-cyl turbo | 8-speed automatic | FWD | 27 / 36 / 31 |
EPA ratings. Class: Large car.
Frequently asked questions
Is the 2020 Hyundai Sonata a good car?
Based on 181 owner complaints filed with NHTSA, the 2020 Sonata rates average: 23% fewer complaints than a typical year of the Sonata at the same age. It is one of the best Sonata years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2020 Hyundai Sonata?
The fuel & propulsion system — 59 complaints, 33% of all complaints for this model year, most often about storage › auxillary tank. Next are the electrical system (40) and engine & cooling (32).
How many recalls does the 2020 Hyundai Sonata have?
There are 4 recalls for the 2020 Hyundai Sonata, the most recent from November 17, 2025 (fuel system, gasoline). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Sonata?
The best years by complaints, compared at the same age, are 2025, 2019 and 2020. Years to avoid or approach with caution: 2011, 2013, 2012, 2015 and 2017. See the full Hyundai Sonata years comparison.
At what mileage do 2020 Hyundai Sonata problems happen?
The median mileage reported in complaints is about 3,000 miles; 80% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.