2021 Hyundai Santa Fe Electrical Problems

Which parts fail

• Horn
  1

Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2021 Hyundai Santa Fe owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2021 Hyundai Santa Fe. The contact stated while the vehicle was stationary at a traffic light, the vehicle turned off and on intermittently. The contact stated no warning light was illuminated. The contact took the key out of the ignition to completely turn off the vehicle. The contact was able to restart the vehicle and drive to her destination. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The contact associated the failure with the recall. The local dealer was not contacted regarding the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. …

12v connector for phone charger melted my phone cord. Reported to Centennial Hyundai Las Vegas and High Desert Hyundai Kingman Az. Both service departments said my vehicle cannot detect the problem because I purchased a substandard plug-in. I have worked as an operator of high voltage electrical systems. I understand in some circumstances that a system cannot detect a fault, however the company is still responsible for the fire it caused. This is unsafe and can cause serious consequences. It must be corrected.

The contact owns a 2021 Hyundai Santa Fe. The contact stated that the horn had become inoperable. There was no warning light illuminated. The dealer was notified of the failure and informed the contact that the failure was a common failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,000.

Car would not start; battery was too low to activate lights or locks, let alone starter. An attempted jumper cable connection to an older car was insufficient to make the motor turn, even after just running the assist car while connected for 20+ minutes. A subsequent jump from the AAA 2000 Ah jump pack did work although their 'test' indicated battery state-of-charge and state-of-health to be less than 30%. Their obvious recommendation was battery replacement and, with the vehicle now running, a drive to the dealership was attempted. At the first intersection a full vehicle stop engaged the engine Stop-Start function, but without sufficient battery for the 'Start' part. …

Car was without power after 16 months and 7500 miles. Got it jump started. Two days after that, car would not start again. Second time jump started. Taken to the dealership (Alexandria Hyundai) where two days after that they found "nothing wrong with the car" and returned it to me. Before that, I asked them to change the battery, they denied my request and I paid out of pocket for a new battery as maybe that was the problem. One month approximately after that, car would not even open. Got it jump started again. Drove to blocks and completely and suddenly shut off in the middle of a busy intersection posing a major safety concern for myself and third parties. Involved 911 and towing. Had to spend 40 minutes depressing the brake for the car not to roll down and avoid an accident. Taken to the dealership again. 5 days after that, dealership found "nothing wrong with the car". …

Horns assemblies are Failing repeatedly. Since ownership of the vehicle (2023 and a CPO Platinum Wrap), I have had to replace a single horn, or both horns three times with local Hyundai dealerships. mostly the right horn would fail, then the left. I am currently making efforts to have my vehicle's horns serviced for the fourth time as they are not working. I have been to my dealership on Dec 16, 2025 & Jan 15, 2026, to have the horns repair to no avail. In December, a diagnosis was performed with no action. Yesterday, one part (horn) was not available, and I was quoted a fee of $400 to perform the task. This is extremely concerning as this is not a consumable part or fluid. This is a required vehicle safety item. There are TSB's for other models in the Hyundai line with similar failure of horns ( TSB's: 24-BE-018H & 25-BE-005H). …

Car was bought approximately a year and a half ago and it was working fine until last September 2022 when it started to stall the engine when having ISG (Idle Stop and GO) ON. It has no pattern, but during the last 2 months it has shut down more than a dozen times. I've taken the car for inspection at Hyundai (2 times so far) and they can't find any faults when running a scan and said that they car is just fine. They assured that an ECM update would solve the issue but it has not improved anything in the car. The car has continued the pattern , when you stop the car it starts to shudders before stalling the engine, all without any error lights. Next November will be the third time bringing the car for the same issue without any resolution. Also, as a minor problem, it has started disconnecting the cellphone from the apple car and you can't reconnect it unless you turn off the car.

Hyundai filed Recall Campaign 236 for the vehicle entering an unsafe state. On July 10th I took in our 2021 Santa Fe Limited with just over 15,000 miles, which had been operating normally with the serious safety defect and received the Remediation for this recall filed under NHTSA Recall Campaign 236. I took possession back of the vehicle and within a few miles of driving had the exact issues the recall remediation was supposed to fix, occur. I lost the ability to safely control the vehicle followed by multiple warning lights displaying and then experienced full loss of power. I could not signal or use emergency blinkers while going at speed on I-405 between mile marker 5 and mile marker 6, this placed everyone around me on the highway at risk. I am deeply concerned that the Recall Remediation for Campaign 236 may not work.

I was accelerating after being at a stop sign onto a major two lane road when all of the warning systems came on and the car stalled while the front of the car was partially on the major two lane road. The alarms, including the collision warning were going off, and it took me several minutes to restart the engine. I was very lucky that I was not hit by oncoming traffic. This was immediately reported to our local Hyundai dealer. They took two weeks to schedule our appointment and then told us nothing was wrong and that everything "checks out". Today, I receive the recall notice telling me the loss of power "could increase the risk of a crash" and yet they do not yet have a fix for it. This means I am paying for a car that is unsafe to use with no remedy in sight. Had this occurred on the highway, I would have been killed.

While driving the crash avoidance emergency braking came on out of nowhere, and the steering locked up. I was driving on a straight and level roadway with no vehicles in front of me when suddenly the whole dash lit up with warning lights and the car, a 2021 Hyundai Santa Fe, came to a emergency stop, the steering wheel was shaking and wouldn't turn. This was the second time this happened. The first time on 09/29/22 I called the car dealer and was told that "They knew of the problem and that there was no remedy". This is extremely dangerous, both times it happened while I was driving on a highway at a steady speed, thankfully the roadway was dry if it had been raining I would have probably crashed.

Electrical complaints in other Santa Fe years