Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2025 Hyundai Santa Fe owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving at various speeds and taking her eyes off the road ahead, there was a warning chime and a red warning light illuminated, advising the driver to "Consider taking a Break". The contact stated that the safety feature is the Driver Monitoring: Camera/Sensor and the safety feature was activating while turning her head or moving her eyes from looking ahead. The contact stated that the chime was loud and was distracting while driving. The contact stated that the failure was almost constant. The contact called a local dealer and was advised that the system could not be deactivated. The dealer referred the contact to the NHTSA Hotline to report the issue. The manufacturer was not informed of the failure. The failure mileage was approximately 700.
The contact owns a 2025 Hyundai Santa FE. The contact stated that while parked and seated in the vehicle, the instrument panel was blinking on and off several times before going dark. The contact stated that the infotainment system also displayed a blank screen. A dealer was contacted. The vehicle was taken to the dealer for a recall repair, and the contact was informed that there was no failure with the instrument panel. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 6,000.
On June 24, 2026, my spouse was operating our 2025 Hyundai Santa Fe when the vehicle suffered a sudden, catastrophic, and total electrical failure while actively on the roadway. The vehicle was stopped at a traffic light when all propulsion power was instantly lost, the engine shut down, and all electronic systems-including the center infotainment screens and instrument cluster-went completely dark. Safety Hazard & Entrapment Incident: Simultaneous with the total electrical failure, the vehicle's electronic door lock system malfunctioned. The rear passenger doors and rear liftgate locked completely and could not be disengaged or opened from the inside by the passengers. Due to this total power loss and lock failure, my young daughters were trapped in the rear seats. …
While driving on the on ramp to [redacted] the car completely stopped and all systems shut off. There were two dash lights that flashed quickly with one being the check engine light but I did not see the other long enough to identify it. The dealership could not reproduce the issue but has the car now and is doing a more thorough evaluation. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine stopped. Yes it is available How was your safety or the safety of others put at risk? Extremely dangerous as it came to a stop in the middle of the road. It was late at night so at that moment no one was behind me. Has the problem been reproduced or confirmed by a dealer or independent service center? no Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? …
Vehicle fails to appropriately recognize when it is put in Park. The dash shows a "P" indicating the vehicle is in park, but emits a continuous beeping sound with a message on the dash that reads, "Auto Stop is Off. Shift to P or N and start engine manually." However, when pressing "P" as it states I must do, it then reads, "Gear already selected," before returning to the previous message. This is all while a "P" is illuminated and beeping is continuous. Throughout this time, if the brake is released, the car begins driving forward as though it is in Drive, not Park. I have 3 separate videos of this happening.To answer the above questions: The vehicle has repeatedly been inspected by a Hyundai dealership and each time I am told the issue cannot be replicated. I am happy to have it inspected again. …
Vehicle experienced sudden loss of power while driving. Transmission warning and ABS warning lights appeared at the same time. The vehicle would not shift properly and began skipping and dropping gears. Smoke was visibly coming from the center underside of the vehicle near the transmission area. There was a strong burning oil or rubber smell inside and outside the vehicle. This created a serious safety risk due to loss of acceleration and potential fire hazard from smoke and burning odor. The issue has been intermittent since early ownership, including jerky shifting and hard engagement. The dealer documented dual clutch transmission communication faults and ABS faults but returned the vehicle the same day stating it was a loose ground. The problem has continued after repair. Vehicle is available for inspection. The defect involves the powertrain and related electrical systems.
I tried to drive my 2025 Hyundai Santa Fe Hybrid; the vehicle displayed a gear selection error message stating something like "gear already selected". The vehicle would not shift properly and would not power off or restart. I attempted multiple shutdown and restart attempts using the Start/Stop button with no success. The vehicle remained in this condition for about 30 minutes and would not allow normal operation or shutdown. Due to safety concerns, Hyundai roadside assistance was contacted and a tow truck was dispatched. Before the tow arrived, the vehicle spontaneously allowed shutdown without any intervention. This was a safety related failure involving the shift-by-wire system and vehicle power-down logic. The issue occurred without warning and left the vehicle inoperable. The vehicle had app 7150 miles at the time of the incident.
On more than 10 occasions the SUV gets stuck in neutral upon starting the car. You can only switch between Park and neutral and are unable to drive the car. It will not go into drive or reverse. Sometimes this problem lasts for 10 minutes. The car will not shut off during that time even when you press the stop button the screen just resets. The only solution is to wait or to press the hard reset button on the computer screen. It is a dangerous situation because if you need to go somewhere, you physically cannot drive the car. I took it to the car dealership when the car was almost brand new and they had it for eight days and they did a software update but I don't think they found the problem. this problem is now having more and more frequently.
The vehicle has two display panels, molded into a single frame. There is an infotainment panel on the right that handles music, maps, and phone interaction. There is an instrument panel on the left. The infotainment panel has not issues. The instrument panel blanks out for 3 - 5 seconds every few minutes, and then reappears. Occasionally the words "No SIgnal" in big red letters will appear. Occasionally the gear selection letter will remain on the otherwise blank screen. The screen also shudders / tears occasionally before blanking. It does this whether the vehicle is moving or parked. I purchased the vehicle used, Jan 2 2026. I noticed the problem a couple of days later. It has continued. It is not getting any worse or any better.
Battery/Electrical: 3 separate occasions the battery drained completely overnight, requiring mechanical key to open and jumpstart services from AAA (covered under Hyundai services). Risk of leaving me stranded on isolated areas. Problem confirmed via 3 requests for AAA to jumpstart my vehicle. Hyundai service dept inspected vehicle, confirmed low battery levels, unable to reproduce issues overnight, reported no electrical or mechanical issues that would cause battery drain. No warning messages, lamps, or symptoms prior to each failure. Steering wheel column has friction squeak when using driver assist and adjusting direction. No issues at this time.
Related recalls
Electrical system › Starter assembly
Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Santa Fe vehicles. The B+ positive terminal cover on the starter motor assembly may be improperly installed, which can cause an electrical short during a crash.
Remedy: Dealers will inspect and reinstall the starter motor terminal cover, as necessary, free of charge. Owner notification letters were mailed beginning October 22, 2025.
Electrical complaints in other Santa Fe years
Frequently asked questions
How common are electrical problems on the 2025 Hyundai Santa Fe?
NHTSA has 28 complaints about the electrical system of the 2025 Hyundai Santa Fe, 21% of the model year's 135 complaints. The component named most often is adas › driver monitoring › camera/sensor (1 mentions).
Is there a recall for 2025 Hyundai Santa Fe electrical problems?
Yes — NHTSA recall 25V-659 (starter assembly, Oct 2, 2025). Recall repairs are free at authorized dealers.
At what mileage do 2025 Hyundai Santa Fe electrical problems start?
Half of the complaints with a recorded mileage happened before about 6,000 miles, and 100% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.