Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Hyundai Santa Fe owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle lost motive power while depressing the accelerator pedal, with the check engine warning light illuminated. The vehicle was taken to a dealer and the turbo was replaced. The contact stated that months later, the vehicle hesitated and jerked while depressing the accelerator pedal with the check engine warning light illuminated. The vehicle was taken back to the dealer where a part on the transmission was replaced; however, the failure returned, and the check engine warning light illuminated. The vehicle was taken back to the dealer and the contact was informed that the transmission needed to be replaced. The contact took the vehicle to an independent mechanic and had the transmission replaced. …
The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving approximately 45 MPH, the vehicle hesitated while accelerating with the accelerator pedal depressed and the RPM raised. The contact stated that the vehicle occasionally failed to start. No warning light was illuminated. Additionally, while driving at various speeds, the vehicle lost automotive power. The vehicle was taken to a local dealer, where it was diagnosed, and determined that there were metal shavings in the oil pan. Hyundai Eugene (89320 N Game Farm Rd, Eugene, OR 97408) was contacted; however, the failure was not identified. Upon further investigation, the Hyundai Blue Link App retrieved DTC associated with the Power Train EMS and Power Train TCU. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure, and a case was filed. …
The contact owns a 2019 Hyundai Santa Fe. The contact stated that on various occasions while driving at various speeds with the automatic START/STOP function activated, the vehicle started losing motive power while the brake pedal was depressed. The contact stated that the failure recurred while driving from a complete stop. The vehicle was able to restart. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that the valve cover gasket needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that the All-Wheel Drive (AWD) warning light was intermittently illuminated. The manufacturer was not made aware of the failure. The failure mileage was 75,500.
The contact owns a 2019 Hyundai Santa Fe. The contact stated while driving from a stop signal, the vehicle experienced a delay while accelerating. The contact stated that the vehicle was jerking without warning. The contact stated that on another occasion while driving 60 MPH, the vehicle inadvertently made a sudden stop without warning. The vehicle was taken to the dealer; however, the mechanic was unable to determine the cause of the failure. The manufacturer was not contacted. The failure mileage was 34,000.
Complaint: Safety Defect - Engine Failure Risk (Stalling/Fire) My 2019 Hyundai Santa Fe has the defective Theta II 2.0L Turbo engine (G4KH), subject of class action In re: Hyundai and Kia Engine Litigation and multiple TSBs. The engine has a known manufacturing defect causing premature connecting rod bearing failure, leading to catastrophic engine seizure. SAFETY CONSEQUENCE: This defect presents a clear, unreasonable safety risk: Sudden Stalling: Engine can seize without warning while driving, causing loss of propulsion and power steering/brakes, leading to a crash. Engine Fire: Failed engines can leak oil onto hot components, causing fires. MANUFACTURER'S INADEQUATE REMEDY: Hyundai's "Knock Sensor Detection System" software update (Campaign 966) only attempts to detect failure moments before it happens. It does NOT fix the underlying mechanical defect. …
we took it in to be looked at after it had a o2 sensor go bad I changed the sensor and checked fluids I noticed the oil was a touch low and it had metal on the dipstick. I took in to dealership for repair / replacement and Hyundai denied the claim. Even after I have video proof from the dealer technician saying there is metal and bearing material in the oil. I took it to another dealership and they found metal in the oil control valve and still denied it. We got the car back because we were not provided a loaner or a rental. I called back in with concern that the car had a weird burning smell and the car would die. Then it started sounding weird as well. Then called again Saturday because I checked oil and it had fuel smell in the oil. Now today it left my family stranded on the highway. …
In December 2025, a Hyundai dealer performed Service Campaign 9C2 (TSB 25-01-087H), an ECU software update for the 2.4L GDI Theta II engine, during a routine annual NY state emissions inspection. Immediately following this update, the vehicle began exhibiting an RPM flare of approximately 1,200-1,500 RPM during upshifting under light acceleration. This behavior did not exist prior to the update. The condition occurs when ambient temperature is above 50 F and the vehicle has been parked 2+ hours after a prior drive. No warning lamps or fault codes have been present at any point. The issue has been confirmed across four dealer visits at two Hyundai dealerships over five months. Attempted remedies included transmission ECU updates and adaptive resets - none resolved the condition. …
My 2019 Hyundai Santa Fe 2.4L (VIN: [redacted]) is experiencing a severe safety defect involving rapid engine oil starvation. The vehicle recently failed an official oil consumption test conducted by Fred Beans Hyundai of Abington, where it was documented that the engine consumed 1 quart of oil in just 881 miles (PA Request #[redacted]). This vehicle is equipped with the Theta II engine, which currently has active warranty extensions (TXXC and TXXI) specifically covering connecting rod bearing failure. Despite the documented severe oil loss-which is the primary known cause of connecting rod bearing wear and sudden engine seizure-Hyundai Corporate (Case #[redacted]) is refusing to evaluate the vehicle under these warranties. …
Transmission was replaced under warranty by Hyundai in Nov 2024. Engine was replaced at 100600 miles in Nov 2025. Issues with the transmission were happening at that time but ignored by dealership as issues related to failing engine. Our mechanic confirmed in April that transmission was failing and told us to go to Hyundai. We went to dealer in April 2026. They confirmed transmission needed to be replaced. They were going to contact Hyundai USA. We received no updates despite many calls to the dealer. We had to call Hyundai USA directly. They opened a case. Dealer finally called and took car in and requested good faith repair by Hyundai USA. Hyundai USA responded 2 weeks later and is not covering anything. They replaced our transmission in Nov 2024 with a refurbished transmission that they NO LONGER MAKE. Clearly due to the fact that the refurbished part doesn't work. …
On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around 10-20 mph when coasting with no accelerator input or when applying very light throttle. Acceleration response also feels slower than before the update, with noticeable hesitation when the accelerator is pressed. The problem is most noticeable during the beginning of a drive when the vehicle is cold. After driving for some time and the vehicle warms up, the symptoms improve, although the change in drivability remains noticeable compared with operation before the update. …
Transmission complaints in other Santa Fe years
Frequently asked questions
How common are transmission problems on the 2019 Hyundai Santa Fe?
NHTSA has 37 complaints about the transmission & drivetrain of the 2019 Hyundai Santa Fe, 18% of the model year's 203 complaints.
Is there a recall for 2019 Hyundai Santa Fe transmission problems?
No. NHTSA lists no transmission & drivetrain recall for the 2019 Hyundai Santa Fe, though it has 2 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Hyundai Santa Fe transmission problems start?
Half of the complaints with a recorded mileage happened before about 16,000 miles, and 60% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 1 injury to transmission & drivetrain problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.