2013 Hyundai Santa Fe Transmission Problems

Which parts fail

• Transfer case (4-wheel drive)
  1

Components named in complaints (automatic and manual transmissions, CVT, axles, driveshaft, 4WD/AWD).

Mileage when the problem started

• Under 25k
  1343%
• 25k–50k
  27%
• 50k–75k
  517%
• 75k–100k
  310%
• 100k–150k
  620%
• 150k+
  13%

Owner reports

Selected complaints filed with NHTSA by 2013 Hyundai Santa Fe owners, lightly cleaned up (personal details are redacted by NHTSA).

my car is burning oil i change the oil often and after a oil change it burns about 1 to 2 quarts every 2000 miles. at 108,000 mile i had a tune up plugs coil packs and fuel injectors my car was putting a code for misfire in 3 and it was cleared after the tune up. then 4 weeks later #4 was misfiring the car is burning more oil and smoking and the knocking and ticking nosie is coming from the car the car doesnt want to start and it vibrates. if you goto drive it feels terrible and unsafe the engine light is on steady i called the hyundai dealer they said there was a engine recall on certian motels my car is in that recall. i have no use of my car and the engine needs to be replaced and the dealer said they have to try to appove it. …

On January 20, 2023 I was on my way home from work and was stopped at a traffic light. The light turned green. As I tried to accelerate forward the engine light started blinking and the vehicle moved slow and lost a lot of power and a knocking sound began. As I tried to accelerate more the knocking sound became louder. I found an engine issue after entering my vin# on the Hyundai site. It was found that for the 2013 Hyundai Santa Fe Sport there was an engine issue. I have attached this issue pertaining to my vin#. I printed this information and took these to my nearest Hyundai dealer, who stated to me that these were not official recall papers and they can't use them. I am the 3rd owner of this vehicle so I never would have received an official recall paper. I proceeded to email consumer affairs at Hyundai and sent these same attachments showing the vehicle issue with my vin#. …

The component is the differential. Yes it is available The differential is leaking oil from the coupling assembly and makes noise while driving like a skip and when you turn to the left and in reverse. Because it helps with the braking time and lessened the risk of things such as vehicle rolling over on curves. I've had my car in for this problem since Jan. 2023 with the dealership telling me and repairing everything but this problem. Took it to two other mechanics that both agree its the coupling . Call the dealership again because Hyundai states they must see the problem are they are 1-3 months out. I have the pictures from mechanic and their sister company did have a recall on the 2013-2020 Sorento that uses the coupling but never a recall on Hyundai. …

My 2013 Santa Fe Sport 2.0t seized. After getting multiple inputs from Licensed Mechanics I was informed about a known recall for my vehicle with symptoms that aligned with the symptoms of my vehicle. That is also listed on the NHTSA re-call list. I contacted Hyundai shortly after that to make them aware of the issue; I got an appointment for an inspection on 04/05. I was informed that my vehicle would not be fixed under the recall because my car was out of warranty. They also stated that I was at fault for a lack of "service"; I am requesting that Hyundai replaces any and all parts necessary + labor considering the fact that this recall is known to cause pre-mature engine wear, engine friction and engine seizure. In addition to this, the dealership marked my vehicle engine re-call as "completed" on 04/05/22 per Hyundai website through running my vehicle in # see attached documents.

Dealership verified several months ago that vehicle engine is burning oil (was initially informed of this issue about 6 months prior from a quick oil change business). In spite of documented evidence of oil changes every 3,000--5,000 miles since purchasing the new vehicle, claim filed with Hyundai for a new engine was denied (engine is 1 year past warranty). On 11/11/23, engine catastrophically failed traveling 70 mph on the interstate (loud "bang" from engine compartment followed by inability to accelerate; created hazard due to density of traffic and vehicle location in the passing lane). Was able to get vehicle to shoulder without incident. Check engine light was blinking. Had vehicle towed to Hyundai of Cookeville, TN. Since then, have struggled to get dealership to determine precise cause of engine failure. (Engine is available for inspection upon request.)

The vehicle is equipped with a Theta II engine. After several months of oil consumption tests Colonial Hyundai in Downingtown PA changed the motor but not the spark plugs. Vehicle became disabled while driving with a clogged catalytic converter which an independent mechanic said was clogged with burnt oil. Hyundai dealership contends excessive oil consumption has negative impact on catalytic converter. This seems to be a performance and possible safety issue for vehicles which were subjected to running while consuming excessive oil.

The engine won't start. The car just shut down. While drive there was a sluggish feel in the car engine. The battery in the car is good. There power everywhere in car except for the engine. The engine shutdown with no warning lights or signals at all. Had the car towed back to Family Hyundai Dealer in Tinley Park Illinois on Friday 9/19/22. Received no results as of yet from the service department. Still waiting on results of why the engine shutdown suddenly.

While driving on the interstate the vehicle suddenly shuddered and immediately died, dash lights were still on but all power was cut off. Cars around me were swerving to avoid hitting me from behind as well as avoiding cars in the inside lane. Thankfully able to coast to the narrow edge of the road without a grave incident. Restarted the car with a terrible metallic screetching noise and limp along the side of the interstate to the nearest off ramp.

I was driving down the highway when the car suddenly just jolted stalled and misfired. I put on my hazards and jerked to get a read since the engine light came on. After 4 diagnostic tests and 3 different mechanics the codes read misfire in cylinder 2. Spark plugs were installed new, but after further inspection and 3 pressure tests the problem was scoring to the cylinder wall, not the cylinder coil itself. The final test was by a Hyundai dealer, but he did not tear down the engine further to find exact cause. He initially suggested an oil change, but I have been getting oil changes every month before service is due as oil is burning off and not lubricating essential mechanical parts. I have records of monthly changes. I also had several issues with brake fluid leaks regardless of tube installation per another recall for ABS system. …

I had lightly let off my gas pedal since I was driving down a slight decline/hill. Upon reaching the bottom of the decline, I pressed the gas pedal to maintain my speed, when I heard a loud noise from my engine; all the lights on the dash lit up; and my car lost all power. These items happened simultaneously and it was very sudden and unexpected as there were no prior warnings, indications, noises, or lights. The steering wheel locked up and I was unable to control the direction of my car. The brakes locked up and were unresponsive despite depressing them with both feet. I had no control of my car and I was completely at the mercy of my car and the road. The electrical system also failed. When my vehicle came to rest, nothing in the car worked. If a child, another vehicle, or animal was stopped in front of me or had pulled out in front of me, my car would have ran right into them. …

Related recalls

NHTSA investigations

Transmission complaints in other Santa Fe years