Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2025 Hyundai Ioniq 5 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2025 Hyundai Ioniq 5. The contact stated that after starting the vehicle, the battery warning light remained illuminated, and the vehicle failed to exceed 45 MPH while driving. The messages "Onboard Charger - Stop Vehicle" and "Power Supply" were displayed. The vehicle was later towed to the local dealer who diagnosed that the ICCU Module had failed and needed to be replaced. The vehicle was not yet repaired. The contact stated that during the failure, the electric battery had failed to recharge the 12-Volt battery as intended, which caused the failure. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in NHTSA Campaign Number: 24V868000 (ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 8,000.
The contact leased a 2025 Hyundai Ioniq 5. The contact stated that while driving at 25 mph, the battery warning light, reduced power warning light, and an unknown warning light depicting a vehicle with an exclamation mark illuminated. Additionally, a "stop vehicle and check power supply" message appeared, and the vehicle lost power. The driver steered to the side of the road, and the vehicle was towed to a dealer. It was diagnosed that the ICCU unit and ICCU fuse were defective and needed replacement. The vehicle was repaired, and the manufacturer was notified of the failure. The failure occurred at approximately 82,069 miles.
The contact owns a 2025 Hyundai Ionic 5. The contact stated that shortly after purchasing the electric vehicle, while charging the battery there was a loud banging and the battery failed to charge. The vehicle was driven to the dealer, who diagnosed that the Integrated Charging Control Unit (ICCU) had failed and needed to be replaced. The ICCU was replaced, but the failure reoccurred. The vehicle was returned to the dealer under the State Lemon Law Act. The manufacturer was notified of the failure. The failure mileage was 200. The VIN was not available.
I was driving to work on the morning of Nov. 12th, 2025 in East Greenwich RI. The car had been fully charged on my home Level 2 charger the night before. It was a chilly morning so I turned on the heated driver seat and steering wheel. Less than a mile from my house, and without any warning or prior issues, I heard a loud pop from underneath the vehicle. Immediately the car displayed an error on the dash reporting electrical system issues. The car still seemed driveable so I began to drive back home, noting that the car wouldn't exceed ~30 mph, but before I went very far at all the error changed to "Stop vehicle and check power supply." I pulled the car over on a side road and called for a tow to the nearest Hyundai service center in North Kingstown, RI. The next day the Hyundai service center reported that their diagnostics revealed that the ICCU had failed. …
The ICCU (Integrated Charge Control Unit) failed. Fortunately I was in a parking lot at the time, as the vehicle limited its top speed to around 25 mph. Had the failure occurred on a highway it could have caused a collision. While this is a 2025 model year Ioniq 5, the ICCU hardware (part 36400-1XAA0) remains unchanged across all Hyundai/Kia/Gensis vehicles sharing the eGMP platform. NHTSA previously issued recall 24V-868 intended to address such ICCU failures. While the modified software is included from the factory in the 2025 model year Ioniq 5, it appears that the 24V-868 recall is not a complete fix. Indeed, ICCU failure continues to be one of the most commonly reported owner issues, both for vehicles which have already had the "fix" from recall 24V-868 and for newer vehicles outside of the recall's scope. …
On the afternoon of Saturday, December 12th 2025 I was preparing my car for a trip an hour north and back to drop my daughter off with her grandmother. I was charging my car with my Level 2 charger and preheating my car. Upon leaving for the trip, within a half mile I heard a loud popping sound coming from the rear of the vehicle and immediately had a warning on the vehicle stating "Stop Vehicle and Check Power Supply". The vehicle soon started to lose drive power, and I had to perform a U-turn and then parked at the nearby Quaill Volunteer Fire Department to perform a basic safety check. Knowing that I probably had the Hyundai Ioniq 5 ICCU issue, I knew that my car would soon have no power so I waited for an opportune time to leave the fire station to coast back to my house. After arriving home, I contacted Hyundai Roadside Assistance and my car was soon towed away. …
I had driven a few miles to a store and was inside for about 10 minutes. I went out to the parking lot and started the car by pressing the button. Within the first couple of seconds after starting, there was a loud pop sound, followed by alerts on the dashboard. Checking the onboard diagnostics, I saw an alert that the charging system had a fault. Using the MyHyundai app, I saw a diagnostic code of P1A9096. I was able to drive home (albeit limited to about 40 MPH on a road with a 50 MPH speed limit and traffic that drives faster than that) and park. …
On December 26, 2025 (six months after leasing this new vehicle) the ICCU unit failed. The mileage is 5,555. This known defect poses serious safety risks as it causes the vehicle to be unexpectedly and immediately disabled. It can drive at only very slow speeds. Drivers must find a safe place as soon as possible to park and call for a tow. Specifically, I was leaving a parking lot and heard a loud pop from behind me. the dashboard immediately displayed a red warning to check the electrical system (which is the drive system in a BEV). Fortunately, I was able to back up back into the parking lot, park and call for assistance. Had I been travelling at highway speeds, it would have been much more dangerous. There was absolutely no warning that this failure was going to happen, so it can occur at any time and any place. The weather was cold and humid. It was raining at the time. …
The vehicle, while driving, displayed an error to "Check vehicle electrical system" and went into a mode that wouldn't allow it to accelerate beyond ~20mph. I was lucky that I was not on the highway, or it would have extremely unsafe. Instead I was on a 45mph road and was only a moderate hazard to traffic passing me. Upon returning home, we called the dealership and were told that we couldn't take it in for 3 days but that it was safe to drive it there, approximately 9 miles. That morning, I made it less than 1 mile as the car wouldn't go above 12mph. It displayed an flashing warning to pull the car over, then the car completely shut down electronically. I was unable to shift to Park or so anything at all. So while I waited 2 hours for a tow truck, I had to stay seated pressing the break in 15 degree weather with no heat. …
On [redacted] my there was a loud pop from the rear of the vehicle and electric vehicle warnings popped up on my dash. I turned around at the light, and as I drove I could tell that the vehicle was slowly losing power. Speed was limited to 30mph. Barely made it back home before the warnings on the dash told me to immediately stop driving. Vehicle was towed to the dealership, and they informed me on January 8, 2026 that the ICCU had went out and blown a fuse, so they needed to replace both. The car is unable to be driven until this is replaced. The current odometer reading is 3,390 miles. I called yesterday, January 21st and was informed that Hyundai has the ICCU on backorder and it will be at least two weeks before they can update me again. I've reached out to Hyundai Motor America National Consumer Affairs. …
Related recalls
Electrical system › Propulsion system › Traction battery
Hyundai Motor America (Hyundai) is recalling certain 2025-2026 IONIQ 5 and 2026 IONIQ 9 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Remedy: Dealers will inspect and tighten the bus bar retention bolts and replace the battery system assembly, as necessary, free of charge. Owner notification letters were mailed April 3, 2026.
Electrical system › Propulsion system › Traction battery
Hyundai Motor America (Hyundai) is recalling certain 2025 IONIQ 5 vehicles. The high voltage battery system may contain an improperly tightened bus bar, which can cause a short-circuit.
Remedy: Owners are advised to park their vehicles outside and away from structures until the recall remedy is complete. Dealers will inspect and repair the high voltage battery system, as necessary, free of charge.
Electrical complaints in other Ioniq 5 years
Frequently asked questions
How common are electrical problems on the 2025 Hyundai Ioniq 5?
NHTSA has 227 complaints about the electrical system of the 2025 Hyundai Ioniq 5, 76% of the model year's 299 complaints.
Is there a recall for 2025 Hyundai Ioniq 5 electrical problems?
Yes — NHTSA recall 26V-068 (traction battery, Feb 5, 2026); NHTSA recall 25V-482 (traction battery, Jul 23, 2025). Recall repairs are free at authorized dealers.
At what mileage do 2025 Hyundai Ioniq 5 electrical problems start?
Half of the complaints with a recorded mileage happened before about 8,000 miles, and 67% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.