2022 Hyundai Ioniq 5 Fuel System Problems

Owner reports

Selected complaints filed with NHTSA by 2022 Hyundai Ioniq 5 owners, lightly cleaned up (personal details are redacted by NHTSA).

I turned on the car and immediately got a "check electric vehicle system" error, and then shortly after a "stop vehicle and check power supply" error. I located a nearby dealership to diagnose and repair the vehicle, and called a tow truck to take it there. My car is parked in a garage in an alley. After the tow truck arrives in the alley, I turn on the car and get the same errors, and pull into the alley. As I'm pulling into the alley, the car start behaving very eratically, not responding well to the accelerator or steering wheel, and then within a couple minutes the display goes blank, completely black, with some white glitchy pixels periodically. Thankfully, I had already put the car into neutral at this point so the car could be pulled onto the flatbed tow truck. Once the displays stopped working, the car was completely unresponsive. …

I was driving 75mph on the freeway and I heard a pop and then the electrical warning system on the car lit up. I lost power to the car and was only able to accelerate minimally. There was a warning of low battery and the vehicle was going to lose power. I turned on my hazard lights and was able to get to the exit and was able to exit the freeway safely. Once the vehicle lost power I was unable to open the charger door, start the vehicle, use any of the key fob functions and had to jump the 12V battery, only to die immediately after. There is no pre-warning to this happening, it just shows the alert and the car loses all power. There are also problems with the vehicle after being plugged in to charge and it says "Charging Unsuccessful", or stops charging after a short period of time. It also will not charge to full capacity at home or the charging station. …

ICCU and High Voltage Fuse blew suddenly and without warning on a 50 mph poorly lit road before sunrise. Vehicle immediately entered limp mode in traffic. Car could not make it safely back home before losing all power in the middle of the road (no warning was given that limp mode was about to fail it just stopped with all screens still on).The dead 12v battery (which the ICCU failed to recharge) made the car completely immobile once it turned off even for towing purposes. Put my safety as a driver and those on the road with me at risk with the vehicle drastically slowing down in the middle of travel with no way for others to pass me. Problem confirmed as the ICCU failure by dealer after finally restoring enough power to get the vehicle in neutral to be towed. The pending recall on this Vin is only pending because it is still sitting waiting for the replacement part a month later. …

Battery conditioning (heating) is required for fast charging at cold temperatures. The current method of enabling this function takes many steps including going into the EV setting to enable this option (since it automatically turns off when changing some settings in the Hyundai Bluelink App), then opening the navigation screen, looking at a map and scrolling though a long list of charging sites, picking the desired charger then starting the navigation and route to that site. This has to be to done while in route to a specific charger, normally this would be on the freeway 20-40 minutes before arrival at a fast charging station. It is a distraction while driving and is an issue with all Ioniq 5's sold from 2022-2024. Hyundai fixed this problem for the 2025 model year but have not do so on the previous cars at this time. …

My 2022 Hyundai Ioniq 5 has experienced two ICCU (Integrated Charging Control Unit) failures, both completely immobilizing the vehicle. First failure: November 2024 Second failure: December 31, 2025 (confirmed by dealer 1/13/26) Downtime: Over 45 days total All recall work and maintenance were performed at the same Hyundai dealer, under active warranty, but the recall did not prevent the second failure. Safety Risk: These ICCU failures cause sudden loss of propulsion, leaving the vehicle stranded and creating a serious safety hazard. The second failure after recall indicates the repair is inadequate. Luckily mine failed at home before departing for an errand, but I am gravely concerned about others not as fortunate or for myself should the issue recur while I am traveling on a public road. Examples of this are reported online in a variety of forums. …

Complaint Summary: Mandated federal safety recall remedies performed on my vehicle have directly induced a cascading, critical safety failure of the vehicle's high-voltage propulsion management system. My 2022 Hyundai IONIQ 5 (VIN: [redacted]) was brought to an authorized dealer on [redacted] at 200,224 miles to complete safety recall Campaign 272 / NHTSA Recall 24V-204 (ICCU Software Update and Fuse Inspection). After receiving this software flash, the vehicle's electrical charging system failed (DTC P0D5C00), requiring a full hardware replacement of the Integrated Charging Control Unit (ICCU) on [redacted]. 142 miles after the physical replacement of the high-voltage ICCU, the vehicle displayed an emergency battery malfunction message on the dashboard. Diagnostic scans reveal active fault code P1BC700 in the Battery Management System. …

The Integrated Charging Control Unit (ICCU) has failed repeatedly on this vehicle. It has been replaced three times by Haselwood Hyundai dealer since the vehicle was purchased new in 2021. Dates: 9/8/2023, 12/19/2024, 9/30/2025 at approximately 17k, 35k, and 50k miles. Each failure presents the same way: the ICCU stops charging the 12V battery from the high-voltage pack, the 12V drains, and warning messages appear on the dash: Check Electric Vehicle System. The vehicle then loses power or will not start and becomes inoperable [on numerous occasions the vehicle lost power/would not start at, leaving family occupants stranded. The vehicle also required jump starts on at least 25 occasions. Safety risk: an ICCU failure can disable the vehicle without meaningful warning. …

On numerous occasions starting May 2024 and continuing through July 2025, my 2022 Hyundai Ioniq 5 displayed a "Check electric vehicle system" error upon starting the vehicle. In June 2024, Hyundai replaced the vehicle's VCM under warranty. In December 2024, the car wouldn't start. Hyundai replaced the 12v battery under warranty. In April 2025, the vehicle would not drive above 20 mph and warned of imminent shutdown while driving and Hyundai eventually replaced the ICCU under warranty. And in July 2025, Hyundai replaced the charging port under warranty. In all, the vehicle has been out service for 95 days while being repaired under warranty and most of those days I was not provided with a loaner vehicle. During the ICCU replacement, I was forced to rent a vehicle two separate times to get to work. …

My 2022 Ioniq 5 RWD died in my driveway in late February after first showing a "Check Electric Vehicle System" warning and limiting the vehicle's speed to 22mph while returning home from a short errand. I was initially able to at least turn the vehicle on, but the vehicle was completely non-responsive within two hours of returning home. If we had been traveling on the highway and/or far from home, we would have been in potential danger due to the low maximum speed and could have been stranded with a non-functioning vehicle due to the complete loss of power shortly after the initial incident. I ended up needing to have the vehicle towed to a dealership roughly 25 miles from my home. …

Despite being up-to-date on recalls for this vehicle intended to address failures with the integrated charging control unit (ICCU), I still experienced an ICCU failure. I was driving along a surface road at approximately 40 mph for about 9 minutes when I heard a pop that sounded like cargo shifting in the rear cargo area. The vehicle then flashed a "Check EV System" warning but otherwise continued to operate normally. About 2 minutes later, there was a warning to stop vehicle and check power supply. After I pulled into a parking lot, I restarted the vehicle, but the errors persisted. I had the vehicle towed to the dealer, where it was diagnosed as an ICCU failure. The vehicle was last charged ~15 hours before the failure on a level 2 charger at a peak rate of 6 kw. The vehicle was driven for about an hour after charging, sat overnight, before being driven when the failure occurred. …

Fuel System complaints in other Ioniq 5 years