Most common 1996 Ford Motor Home problems
Share of the 11 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Motor Home complaints by model year
Best Motor Home years: 1998, 1996, 2003. Years to avoid: 1999, 2000. Compare all years →
What 1996 Ford Motor Home owners say
Wheels & tires
Firestone steel tex lt22575r16. Consumer has experienced three steel belt separations, and blowouts within 29,000 miles. They equipped a motorhome. Firestone was contacted. Left and right front tires blew out. Also one right rear tire blew out. These tires should be defective according to the customer.
Firestone steeltex radial r4s tires (p225 75 r16) experienced 4 tread separations, which also caused damage to the vehicle, the consumer is requesting that the remaining tires be replaced and that the damage to the motorhome be fixed.
Fuel & propulsion system
This motorhome only has 17,000 miles on it and it has had 4 fuel pumps on it and is getting ready to have the 5th one. They have all been original Ford parts costing $450 each. It is a faulty design and Ford knows it! This is a 36 ft chassis and the style of tubing and pump cannot keep up, they keep burning up. Ford changed the style of fuel pump that requires a jumper harness kit to keep this from happening but did not issue a recall on any of these. Now that I am again having issues with this fuel pump I feel it is only fair that Ford fix this issue. I have a motorhome with only 17,000 miles on it that has $2000 just in fuel pumps alone not counting any labor and they want to say it's not a design issue when all over the internet and even their forums' it clearly is and has been a problem. Look at article no. 97-23-9 that is just one! …
Tl* the contact owns a 1996 Ford e-350 callista Motor Home (na). The contact noticed propane leaking, a cracked fuel line, and the chassis was unstable. The vehicle was taken to a dealer where it was diagnosed that the propane regulator, tie rod, ball joint, and drive lines needed to be replaced. The vehicle was not repaired. The VIN was not provided. The manufacturer was not notified of the failure. The approximate failure mileage was 110,000.
Speed control & acceleration
1996 Ford econoline motorhome with a recall for fused jumper cable. Consumer states that the dealer told him they didn't have the requested repair part and to call back. He states that the recall states that there is another way to repair this problem. The recall stated an incompatible fused jumper cable May have been installed in vehicles and if the proper fused jumper cable was not available, a new mating electrical switch would be its replacement.
1996 motorhome with recall for speed control switch. Consumer states that the dealer told him that the parts were on back order and to call back in 30 days. Consumer states every month he is told that the parts are not available.
Frequently asked questions
Is the 1996 Ford Motor Home a good car?
Based on 11 owner complaints filed with NHTSA, the 1996 Motor Home rates average: 20% fewer complaints than a typical year of the Motor Home at the same age. It is one of the best Motor Home years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 1996 Ford Motor Home?
The wheels & tires — 3 complaints, 27% of all complaints for this model year, most often about tread/belt. Next are the fuel & propulsion system (3) and speed control & acceleration (3).
How many recalls does the 1996 Ford Motor Home have?
NHTSA lists no recalls for the 1996 Ford Motor Home. You can still confirm with your VIN using our VIN recall check.
What are the best and worst years of the Ford Motor Home?
The best years by complaints, compared at the same age, are 1998, 1996 and 2003. Years to avoid or approach with caution: 1999 and 2000. See the full Ford Motor Home years comparison.
At what mileage do 1996 Ford Motor Home problems happen?
The median mileage reported in complaints is about 110,000 miles; 50% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.