Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2017 Ford F-350 SD owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2017 Ford F-350 equipped with Goodyear Tires, Tire Line: Wrangler All Terrain Adventure, Tire Size: LT275/70/R18, DOT Number: (N/A). While the contact's friend was driving 55 MPH, there was a blowout of the rear passenger's side tire. The driver prevented a crash; however, the failure caused a significant amount of damage when the truck bed lowered and nearly separated from the chassis, the hubcap detached, and the exhaust pipe was bent in half. The driver pulled over to a truck stop and installed the spare and secured the truck bed to the frame with harness straps to prevent the truck bed from separating. The contact notified the manufacturer about the failure and requested that the tire be shipped for inspection to determine any potential liability. The contact had not yet submitted the tire or any documentation to the manufacturer. …
The contact owns a 2017 Ford F-350. The contact stated that while hauling various materials at various speeds, the tire pressure warning light would illuminate the instrument panel. The contact had initially taken the vehicle to the dealer where they discovered that the valve stems on each of the outside tires had caused air to leak out of the tires. The contact had several valve stems replaced on multiple occasions; however, the failure had persisted. The manufacturer had been notified of the failure on separate occasions and two cases were filed with the manufacturer. All of the valve stems were initially replaced under warranty but since the warranty had expired, the manufacturer refused to offer assistance. The vehicle had yet to be repaired. The failure mileage was approximately 10,000.
The contact owns a 2017 Ford F-350. The contact stated while driving 65 MPH, the vehicle began to vibrate and the brake pedal was depressed to gain control of the vehicle however it failed. The vehicle began bouncing and the front passenger's side tire exploded. The contact sustained injuries to her neck but did not receive medical attention. The vehicle was towed to the dealer. A police report was filed. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 43,000.
Goodyear Wrangler All-Terrain Adventure, LT275/70R18 Tire installed new on [redacted] at 79892 miles. Tires were properly maintained including proper inflation and rotated. On [redacted] at 112745 miles the driver side rear tire suffered a sudden and catastrophic tread separation failure. At the time of failure, tire had been in service for 33 months and 32,853 miles, and had significant tread life remaining. Vehicle was travelling at approximately 55 mph on an asphalt highway on a hot, dry day. The separated tread damaged the rear body panel and severed the body structural support member in half. The vehicle was brought to a controlled stop, the separated tread was retrieved from the roadway, and the spare tire was installed. The tire was replaced the following day. …
Factory Ford 20" wheels with Factory Installed Michelin 275/65 R20 LTX A/T2 tires. Tires have just under 30,000 miles on them and still have more than 50% tread. Tread wear is even. Tires have been rotated. Truck has 73,000 miles but had different wheels and tires for first 43,000 miles. I stored these wheels and tires inside climate controlled building. When my aftermarket tires wore out, I put these back on. They had 10 miles on them when I took them off. I have had them on since April 2022. On Friday June 5th, 2026 I was traveling about 60 MPH and had a catastrophic blow-out of the passenger side rear tire. The tires blew completely apart and the wheel hit the ground and the back side of the wheel broke off, before I could get over to the side of the road the tire beat the bed and running board to pieces and even damaged the exhaust and bumper. The wheel was ruined. …
The contact owns a 2017 Ford F-350. The contact stated that while the vehicle was parked, he noticed that the rim was corroded around the valve stem, causing tire to become deflated. The contact stated that the failure had caused him to inflate the tire each time he drove the vehicle. The low tire pressure warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that there was incompatibility with the valve stem and rim. The valve stem was replaced; however, the failure recurred. The vehicle was taken back to the dealer for repair, and the dealer informed the contact that the parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the dealer for assistance. The failure mileage was unknown.
I have experienced multiple issues with my wheels valve stems leaking. I have gotten a couple stems replaced and the problem persists. I am adding air to my tires nearly everyday. I have read a lot of threads online with owners of the same year, make, and model are having the same problems. This is a safety concern because my family and I use this vehicle for travel and I cannot be having flat tires or be stranded because my tires won't hold air. This truck has been to the dealer multiple times for this. Ron Tirapelli Ford Shorewood IL. The vehicle was also purchased there. I receive warning lights for low tire pressure regularly.
That the intersection of 1010 and Rhodes Road 6204 Ten-Ten Rd, Apex, NC 27539.. I have been driving it and steady crossing my fingers hoping to God my tires don't fly off and hurt somebody or kill somebody or me... I just can't do it anymore, I have got to get the thing in the shop it's got the death wobble and is just starting to scare me.. I love my truck I was trying to give them the benefit of the doubt but it's definitely got a problem I honestly think it may be several different things but at any rate it needs to be fixed
Truck has only 70,371 mile on it and the RTM Module associated with the TPMS (Tire Pressure Monitoring System) failed and must be replaced, at owners expense. The TPMS is NHTSA mandated safety requirement. There should be specific published performance standards and expectations. Example: it is known the sensors themselves are battery operated and have an estimated battery life of 5-7 years. The RTM module is permanently mounted to the vehicle frame/body and should carry a reasonable published life expectancy.
The Tread on these tire started separating prematurely. I Purchased 4 of these at the same time and fear the others may do the same. Others using the same tire with similar manufacture dates report the same issue. Tires are being used on our Fifth Wheel Trailer but the previous page would not recognize the Vin. That vin is [redacted] Tire Size ST235/80R16
Wheel & Tire complaints in other F-350 SD years
Frequently asked questions
How common are wheel & tire problems on the 2017 Ford F-350 SD?
NHTSA has 66 complaints about the wheels & tires of the 2017 Ford F-350 SD, 11% of the model year's 574 complaints. The component named most often is rim (2 mentions).
Is there a recall for 2017 Ford F-350 SD wheel & tire problems?
No. NHTSA lists no wheels & tires recall for the 2017 Ford F-350 SD, though it has 13 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2017 Ford F-350 SD wheel & tire problems start?
Half of the complaints with a recorded mileage happened before about 15,000 miles, and 64% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 1 injury to wheels & tires problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.