Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2015 Ford F-250 SD owners, lightly cleaned up (personal details are redacted by NHTSA).
While merging onto an interstate the truck began to violently shake causing me to begin to lose control. I was able to brake hard and pull off the road before I lost complete control. I was extremely upset after this event. After regaining composure on the side of an interstate I pulled back onto the interstate. Within the next 10 min I hit a bump in the middle of the interstate and the truck again began to shake violently. I thought I was going to lose control and crash. We immediately had the vehicle taken to a mechanic. The work they did cost 1300$. Approximately 2 weeks after getting the vehicle back I was driving over a bridge and the seam in the road again caused the truck to violently shake. Again feeling like I was going to lose control. I was able to brake hard and pull over on the side of a bridge. This caused significant trauma to myself and my young son. …
The contact owns a 2015 Ford F-250. The contact stated while driving approximately 65 MPH, the vehicle drove over a slight bump on the roadway and the steering wheel began to move left to right and the vehicle was shaking and unable to maintain a straight line in the lane. The contact stated he was not aware of any warning lights being illuminated. The contact pulled off the road and placed the vehicle in park(P) and waited with the engine running. The contact was able to drive the vehicle to a dealer. The dealer diagnosed the vehicle and determined that the ball joints and the steering dampener needed to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 144,000.
The contact owns a 2015 Ford F-250. The contact stated while driving 50 mph, the steering wheel began to shake forcefully. The contact stated no warning light was illuminated. The contact was able to park on the side of the road for a few seconds and continued to drive to his destination. The contact took the vehicle to a local dealer, where it was diagnosed with needing the steering damper to be replaced. The vehicle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, the Vin was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 97,500.
The contact owns a 2015 Ford F-250. The contact stated while driving and exceeding 60 MPH, while driving over a bump or pothole in the roadway, the vehicle started shaking violently in the front end. The driver depressed the brake pedal, and the vehicle decelerated to 30 MPH. There were no warning lights illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 20N04. The local dealer was contacted, and the vehicle was diagnosed, and it was determined that the steering damper rod needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and informed the contact that there was no recall for the failure. The failure mileage was approximately 150,000.
The contact owns a 2015 Ford F-250. The contact stated while driving 65 MPH, the vehicle experienced the death wobble, causing the contact to lose control of the vehicle. There was no warning light illuminated. The contact was able to regain control of the vehicle once the vehicle had slowed down. The contact stated that the violent shaking also ceased after slowing down. The vehicle was taken to a dealer where the tie rods and all four tires were replaced; however, the failure returned approximately 30,000 miles later. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.
Death wobble - on numerous occasions we have experienced the death wobble on our vehicle. We have complained to several dealers and done their recommended repairs. We have even purchased new high end tires as recommended with no resolution. We are unable to haul our RV out of fear of an accident. It has occurred at high speeds on the highway and at lower speeds on roads. This is very scary when it occurs. Coming to a full stop in a one lane HOV lane is not only dangerous for us but also dangerous for those traveling behind us. This has been occurring for years with the most recent occurrence this week. After researching we discovered this route to file a complaint.
The contact owns a 2015 Ford F-250. The contact stated while driving 50-65 MPH, the vehicle experienced the death wobble, almost causing the contact to lose control of the vehicle. There was no warning light illuminated. The contact depressed the brake pedal and came a complete stop. The contact was able to continue driving; however, the failure reoccurred several times while driving. An unknown dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 92,000.
The contact owns a 2015 Ford F-250. The contact stated while driving and exceeding 55 MPH, the vehicle would shake abnormally. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle with an unstated linkage failure. The vehicle was repaired. The contact stated that the failure had reoccurred. The manufacturer was not notified of the failure. The approximate failure mileage was 37,000.
The contact owns a 2015 Ford F-250. The contact stated that the vehicle experienced the death wobble while driving at various speeds. The contact took the vehicle to the dealer and an unknown repair was performed; however, the failure persisted. The manufacturer was made aware of the failure and confirmed that the repair was not covered under the warranty. The approximate failure mileage was 87,000.
On 03/19/2022 at about noon I was driving my F-250 eastbound on SR 60 (Courtney Campbell CSWY) headed to Tampa, FL. this was a Saturday & the area was very congested. The speed limit is 60 mph. I was traveling about 50 to 55 mph. Suddenly the truck started to vibrate at a rate that it actually bounced or jumped on the road. It was everything I could do to maintain control & get the vehicle slowed down & off the highway. I thought I had a wheel(s) coming off the vehicle. I inspected the tires/wheels/overall vehicle before getting back on the road & returning home. On Monday 03/21/2022 I contacted Ferman Ford in Clearwater, FL to get it in for service to determine what is the problem. Ferman Ford could not get to my truck until 03/29/2022. I then went on-line to see if anyone else has had a similar problem. …
Steering complaints in other F-250 SD years
Frequently asked questions
How common are steering problems on the 2015 Ford F-250 SD?
NHTSA has 126 complaints about the steering of the 2015 Ford F-250 SD, 43% of the model year's 296 complaints.
Is there a recall for 2015 Ford F-250 SD steering problems?
No. NHTSA lists no steering recall for the 2015 Ford F-250 SD, though it has 2 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2015 Ford F-250 SD steering problems start?
Half of the complaints with a recorded mileage happened before about 70,000 miles, and 11% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.