2013 Ford Explorer Suspension Problems

Which parts fail

• Front › Wheel bearing
  1

Components named in complaints (struts, shocks, control arms, ball joints, springs).

Mileage when the problem started

• Under 25k
  715%
• 25k–50k
  49%
• 50k–75k
  511%
• 75k–100k
  715%
• 100k–150k
  1328%
• 150k+
  1022%

Owner reports

Selected complaints filed with NHTSA by 2013 Ford Explorer owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 75 MPH, the vehicle became difficult to maneuver and the front passenger's side of the vehicle crashed into the shoulder lane wall. No warning lights were illuminated. The air bags had not deployed. No injuries were sustained; however, medical attention was sought. A Police report was not filed. The vehicle was towed to a dealer where it was diagnosed that the axle on the front passenger's side wheel was cracked and needed to be replaced. The dealer informed the contact that the engine mounts also needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 133,000.

The contact owns a 2013 Ford Explorer. The contact stated that the vehicle was taken to the dealer for a recall repair related to a possible rear suspension toe link fracture. The contact stated that while his son was driving 55 MPH, a month and half after the recall repair, the rear driver's side tire had a blowout, causing the vehicle to swerve and to drift into another lane. The contact stated that there was no oncoming traffic during the failure. The driver was able to pull over to the right side of the road. The contact then met his son on the side of the road, and the contact replaced the rear driver's side tire with the spare tire. The contact then drove to the residence and inspected the tire. The contact noticed that the inner side edge of both rear tires were prematurely worn. The contact related the failure to the recall repair. …

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 55 MPH, the steering wheel became difficult to move. The contact pulled over and the steering wheel seized. The contact turned the vehicle off however, the steering wheel failed to regain proper functionality. The vehicle was towed to the dealer where it was diagnosed and determined that the steering wheel had failed due to a failure with the suspension. The contact was informed that the failure was related to an unknown recall for which the vehicle was previously included in. The dealer informed the contact that the vehicle could not be repaired free of charge because the VIN was not currently included in any recalls. The contact was informed that the steering assembly needed to be replaced. The vehicle had not been repaired. …

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 70 MPH, the power steering failed to operate as needed. The contact stated no warning light was illuminated. The contact stated that the failure had become a recurring failure. The contact also stated that when the Lane Departure: Lane Keep: Automatic Steering was engaged, the function independently disengaged, and the vehicle was drifting out of the lane. The contact pulled over and turned off and restarted the vehicle and the functionality returned. Additionally, the vehicle was taken to an independent mechanic and was notified of a failure with the rear suspension related to NHTSA Campaign Number: 21V537000 (Suspension) rear toe link. The contact related the steering failure to NHTSA Campaign Number: 14V286000 (Steering). …

The contact owns a 2013 Ford Explorer. The contact stated 6 months after installing new tires on the vehicle, the front tires were damaged. The vehicle was taken to an independent mechanic, where it was inspected, and the mechanic determined that the shocks, the control arms, and rack and pinion failures had caused damages to the tires. The mechanic informed the contact that the front tires, the shocks, the control arms, and the rack and pinion needed to be replaced. The vehicle was being repaired. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in an unknown recall. The failure mileage was approximately 90,000.

The contact's father-in-law owns a 2013 Ford Explorer. The contact's father-in-law received notification of NHTSA Campaign Number: 20V675000 (Suspension). The contact stated that while her father-in-law was driving at an undisclosed speed, the rear end of the vehicle was sliding. The vehicle was towed to the dealer, where it was diagnosed that the rear toe link was fractured, the rear wheel knuckles were seized, and the rear passenger's side wheel bearing was loose; however, the dealer declined to perform the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to tow the vehicle to another dealer and file a complaint with the NHTSA Hotline. The failure mileage was approximately 160,000.

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact indicated that while driving over a bump in the roadway, there was a clunking sound coming from underneath the vehicle. The cause of the failure was not determined. VIN tool confirms parts are not available. The failure mileage was 112,000.

The contact owns a 2013 Ford Explorer. The contact stated while pulling out a parking lot, the vehicle lost power steering functionality with the power steering assist warning light illuminated. The vehicle was not diagnosed. On another occasion, the contact stated while driving 30 MPH, there was an abnormal sound coming from the vehicle. The vehicle was taken to an independent mechanic, and the contact was informed that the wheel hub needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that the VIN was not included in NHTSA Campaign Number: 14V286000 (Steering) or 17E048000 (Wheels, Suspension). The failure mileage was 155,000.

The contact owns a 2013 Ford Explorer. The contact stated while driving 30 mph, the passenger's side rear wheel detached from the rear suspension causing a loss of steering control. The contact stated no warning light was illuminated. The vehicle was towed to an independent mechanic and was diagnosed with the rear lateral links needing to be replaced. The vehicle was repaired. The contact was relating the failure to NHTSA campaign number: 20V675000 (Suspension). The manufacturer had been informed of the failure and informed the contact that the VIN was not included. The failure mileage was approximately 74,540.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the PTU. The contact was also informed that the rear differential needed to be refilled. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V537000 (Suspension), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 93,000.

Related recalls

Suspension complaints in other Explorer years