2022 Ford Expedition Electrical Problems

Which parts fail

• Instrument cluster/panel
  1

Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).

Mileage when the problem started

• Under 25k
  250%
• 25k–50k
  125%
• 50k–75k
  125%
• 75k–100k
  00%
• 100k–150k
  00%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2022 Ford Expedition owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2022 Ford Expedition. The contact stated while driving approximately 40 MPH, the instrument panel went black. The horn failed to be as loud as designed. The contact also stated that while driving approximately 45 MPH and making a left turn, the turn signal failed to activate. The contact stated that the instrument panel was black during the failure. The contact stated that before the failure, the Bluetooth Sync system had failed, and the contact believed that was when the failures started. The vehicle was taken to the dealer who was unable to determine the cause of the failure. The instrument panel and the touch control panel screen were replaced. The contact stated that after the repairs were completed, the back over prevention alarm was not as loud as before. The vehicle had not been taken to the dealer to be diagnosed or repaired. …

The contact owns 2022 Chevrolet Expedition. The contact stated that while driving at various speeds and activating the turn signals, the turn signals would temporarily blink excessively fast, which indicated a turn signal failure. The vehicle was taken to an unknown local dealer, who was unable to duplicate the failure. No service was performed. Additionally, the contact stated that while the adaptive cruise control mode was activated, the vehicle accelerated unintendedly and nearly hit a pedestrian. The contact stated that he had not engaged the Resume button at the time of the failure. The contact also stated that while reversing, the rearview camera was inoperable. The cause of the failures were not determined. The vehicle was not diagnosed nor repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was 6,000.

The contact owns a 2022 Ford Expedition. The contact stated that while the vehicle was parked, it failed to start with several unknown warning lights illuminated. The vehicle was jump-started. The dealer was contacted, but the vehicle was not repaired. The manufacturer was notified of the failure. Additionally, the contact stated that the air bag warning light continuously remained illuminated. The failure was associated with NHTSA Campaign Number: 23V847000 (Steering, Air Bags); however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.

The contact owns a 2022 Ford Expedition. The contact stated that while her husband was having a light bulb replaced, the dealer became aware that the electrical wiring was damaged due to rodents chewing on the wiring insulation. The vehicle was repaired but the failure persisted. There was no warning light illuminated. The manufacturer was notified of the failure. The failure mileage was 22,489.

For the fourth time our brand new Ford Expedition has had a issue with the SYNC radio B&O Sound system. It initially started out where the 15.5 inch screen locked up and no radio, Bluetooth would work and couldn't even control climate. The dealer got to see this first hand and had no interest in investigating. Now the last three times has been a HORRIFYING pop and extremely loud static and popping like fire works inside the car. Two of the three times luckily my wife wasn't driving. The most recent time this happened as we were driving down the road and THANKFULLY no car was in the opposite lane as it caused me to jump and swerve because i though we had been hit. This could have ended very badly under the wrong timing and especially with my 4 year old and infant in the car which they also started screaming because it was ear piercing. …

The contact owns a 2022 Ford Expedition. The contact stated while driving at various speeds, the infotainment screen went blank without warning. Occasionally the vehicle would inadvertently shut off once the screen went blank. The contact stated that the adaptive driving system feature would independently active, causing the vehicle to jerk out of the driving lane, and the contact would temporarily lose control of the vehicle. In addition, the contact stated that the vehicle would independently surge forward upon depression of the brake pedal without warning; while in reverse(R) or drive(D). The vehicle was taken to the dealer on multiple occasions however, the parts to repair the vehicle were on backorder. The contact filed a complaint with the manufacturer. The vehicle was not repaired. The failure mileage was unknown.

Receiving Front Camera Malfunction Service required warning. Also receiving pre-collision assist, adaptive cruise control and automatic emergency break system warnings. Other systems likely disabled. Found that there was a TSB issued for the same year but on the F-150. DTC's C1001:31, U3000:89, U3000:49. This issue is likely caused by faulty cable connections where condensation has caused corrosion making the system inoperable thus creating a major safety issue for owners. I took the Expedition to SawGrass Ford in Sunrise FL and they confirmed that the issue was due to the electronics/cables. The camera itself was not dirty or blocked. They charged me $250 for a diagnostic and then wanted to charge me $2500+. For the safety and security of all owners please investigate and hold FORD accountable for this.

I just had the same issue described in the forum listed below. Extremely loud max volume screeching static through the speakers. Tried turning the car off and on several times, tried turning the radio off, tried switching to Serius xm radio, nothing would make it stop and it was completely unsafe to drive it like that. It was too loud to hear anything else over it and it was so jarring. I now have a headache and i'm nervous to drive it for fear of it happening again. My husband had to disconnect the battery to get it to stop. I have a video but it doesn't seem like I can upload it here, only pics. https://www.f150gen14.com/forum/threads/extremely-loud-electrical-pop-followed-by-loud-static.9591/page-4

Since purchasing this vehicle in January of 2023, it has been to the dealer three times to repair a failed blind spot monitoring system and rear cross traffic alert system due to corroded pins in the connectors of the sensors. According to the dealer, this is due to the connector utilizing only four of eight pins which leaves four pins unused and open to corrosion. On the third trip in, the dealer applied, "super glue" to try and prevent any future corrosion. While there was not a specific accident related to this, I do believe this has the potential to cause issues in the future if not properly addressed by Ford. See attached pdf from dealer for additional supporting information.

ABS break lights and Service Advanced Trac lights flashing and beeping. Eventually Break fluid low lights came on and car would not break when driving . Leaked break fluid on driveway. Car was unable to be driven, no breaks .all happened very quickly and without any reason .i had it towed to a break mechanic and he said it was the ABS modular break line that was broken and there was no more break fluid and it had leaked out . He suggested I send it to the dealership. It sounds like the exact same issue as the recall # 25S47 on campaign 25V314 but my vin number does not fall under they but shows it is the same Kentucky plant and year so I do believe it is the same issue

Related recalls

Electrical complaints in other Expedition years