Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Ford Escape owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, there was white smoke coming from the rear driver's side and there was a burning odor. The vehicle was parked and the contact noticed smoke coming from the driver's rear side of the vehicle. No warning lights were illuminated. The fire was extinguished by the Fire department but the cause of the fire was undetermined. There was damage to the contacts home as a result of the fire. A fire report was filed. The contact's son required oxygen as a result of the fire but it was unknown if medical attention was required. A police report was not filed. The vehicle was towed by the insurance agency to investigate the failure. The dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.
The contact owns a 2019 Ford Escape. The contact stated that while driving at various speeds, the vehicle failed to accelerate while depressing the accelerator pedal. The check engine warning light was illuminated, and the contact received an unknown notification through the Ford Mobile App. Upon inspecting the vehicle, the contact discovered that the high-pressure fuel pump was damaged. The contact replaced the high-pressure fuel pump and the cam shaft follower. The contact stated that two months after the repair, the failure reoccurred. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel injectors and the high-pressure fuel pump had failed. The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the vehicle was not covered under warranty, and the contact was provided a diagnostic test fee. …
The contact owns a 2019 Ford Escape. The contact stated that the vehicle failed to immediately start-up after refueling the vehicle. The accelerator pedal needed to be depressed to the floorboard before the vehicle would start-up. Additionally, the vehicle failed to properly accelerate after starting the vehicle. The check engine light illuminated several weeks after the initial failure. The vehicle was taken to a dealer where a diagnostic test was performed, and the contact was informed that the canister solenoid was inoperable. The canister solenoid was repair; however, the failure returned immediately after refueling the vehicle. The vehicle was then taken to an independent mechanic and a DTC was retrieved. The failure was related to an inoperable Oxygen sensor which was connected to the purge valve. …
The contact owns a 2019 Ford Escape. The contact stated while driving approximately 75 MPH, the vehicle started to stall and lost motive power. The contact stated that it was like gasoline was not getting to the engine. Additionally, the contact stated that she had been having difficulty shifting the vehicle into drive (D) or park (P). The contact stated that when she shifted the vehicle into the selected gear, the vehicle would hesitate before moving and then abruptly respond. The contact stated that the check engine light was illuminated. The contact drove the vehicle to an independent mechanic who diagnosed that the vehicle needed the canister purge valve replaced. The vehicle had not been repaired. …
The contact owns a 2019 Ford Escape. The contact stated while driving at an undisclosed speed, there was an abnormal humming sound coming from the passenger's side rear of the vehicle. There was no warning light illuminated; however, a message to turn off and restart the vehicle was displayed. The vehicle was driven to the residence. The vehicle was started; however, the steering wheel was locked. The message to turn off and restart was displayed again. The vehicle was taken to an independent mechanic where it was diagnosed with a failed purge valve. The contact was informed that the purge valve needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall; however, the VIN was not under recall. …
The contact owns a 2019 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated and remained illuminated. The contact drove to the gas station and while refueling, there was an abnormal fuel odor coming from the vehicle. After restarting and driving the vehicle back to the residence, the fuel odor inside the cabin of the vehicle was extremely strong, causing the contact to have a headache. The contact took the vehicle to a local dealer who inspected and diagnosed the failure as the emission evap valve was not properly separating the fuel inside the fuel tank. The vehicle was not repaired because the local dealer did not have the parts needed to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.
The contact owns a 2019 Ford Escape. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed that the canister purge valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the warranty had expired. The contact was advised to call the NHTSA Hotline to file a complaint. The failure mileage was approximately 45,000.
Vehicle is my wife's car. Vehicle lost acceleration during rapid acceleration attempts (freeway on-ramps, etc.). Threw engine light with P0087 code (Low fuel rail pressure). Brought to local dealer to diagnose and was told the diverter valve failed, which caused the water pump to leak and then caused transmission to overheat. The total quote for repairs was over $8,900. None of this made sense. Did a static pressure test for over 45 minutes on coolant system and never lost pressure. That told me the water pump wasn't leaking. Decided to replace high pressure fuel pump and upon replacing found that the spring on the pump had wore down and punched a hole in the tappet that goes to the camshaft. Replaced high pressure pump, tappet, and fuel manifold from the pump. Pump ($245), fuel manifold ($20), tappet ($10). …
I am reporting a dangerous manufacturing defect regarding internal engine coolant intrusion on my 2019 Ford Escape SEL at less than 70,000 miles. Upon starting the vehicle after it sat parked overnight, a massive cloud of heavy white smoke erupted from the exhaust system and both sides of the vehicle, clearing after 1-2 minutes. The vehicle also exhibits a severe structural shudder and a mechanical groaning noise when shifting gears due to engine misfires caused by this leak. A physical inspection confirmed that the engine cooling system is losing fluid (which was just topped off again last night), which is leaking directly into the combustion cylinders overnight. This is a well-documented factory design flaw involving the engine block casting on Ford EcoBoost engines (referenced in Ford Customer Satisfaction Program 21N12 and multiple Technical Service Bulletins). …
Ford only showed one code P0403 tuneup with a written statement I asked for wanting 15k for a new engine and verbal;y stating I need a whole new engine. The 2019 Ford escape began to smoke heavily while driving. I put over had the car towed to Ford dealer in sandy springs. As Ford is stating that this car needs a new engine the old recall existed from years ago has expired on the VIN number 2022. Just because I made a purchase from 2024 doesn't mean the the issues have been resolved and you should be aware and know about the mechanical issues and list them remained as a recall. The 2020 model also shows major concerns in fact from 2012 to 2020 models Ford escape complaints are listed on your website repetitive recall mechanical issues unfixed or part not available should be all listed as a recalls safety of drivers. …
Fuel System complaints in other Escape years
Frequently asked questions
How common are fuel system problems on the 2019 Ford Escape?
NHTSA has 26 complaints about the fuel & propulsion system of the 2019 Ford Escape, 4% of the model year's 596 complaints. The component named most often is storage › evaporative emissions › canister (3 mentions).
Is there a recall for 2019 Ford Escape fuel system problems?
No. NHTSA lists no fuel & propulsion system recall for the 2019 Ford Escape, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Ford Escape fuel system problems start?
Half of the complaints with a recorded mileage happened before about 63,000 miles.
Is it dangerous?
Owners linked 1 crash, 1 fire and 2 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.