Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2010 Ford Escape owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2010 Ford Escape. The contact stated while driving approximately 35 MPH, the vehicle started shaking abnormally. The contact stated she was safely able to slow the vehicle to approximately 10 MPH and proceed back to her residence. The contact stated that on her way to the residence she noticed that the power steering warning light illuminated, and the steering wheel was difficult to turn. The contact called an independent mechanic and informed the mechanic of the failure. The contact was notified of NHTSA Campaign Number: 15E045000 (Suspension) and 14V284000 (Steering). The local dealer was contacted but the contact was informed that the vehicle was not included in the recalls and that the repair would be an out-of-pocket expense. The manufacturer was not notified of the failure. The failure mileage was 140,000.
The contact owns a 2010 Ford Escape. The contact stated while his daughter was driving at an undisclosed speed, the vehicle continuously pulled to the right, requiring the driver to make constant corrections. Upon visual inspection of the vehicle, the contact observed that the front passenger's side tire was angled inward and had nearly detached from the vehicle. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the front engine cradle after observing excessive corrosion. The vehicle was repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 122,000.
Driving down the road started hearing minor noises in the rear, then louder clunks when driving over road patches and bumps. Parked in our driveway, and inspected, found out the entire strut tower on the rear driver side tire is rusted from the frame and there is a large crack that has formed in the unibody has well. Our local Ford dealership in town sent us to the auto body shop and the auto body shop will not touch it and said park it and do not drive it. It is dangerous to myself, occupants and others on the road you can move the entire strut tower. We are stuck with a loan for a vehicle when we bought had no rust marks anywhere until after a few months. Also the roof leaks as well which was not visible when we purchased this vehicle of a lot. We took it back to the dealership we bought it from and since we bought as is, they would do nothing. …
The vehicle started making occasional "clunking" sounds upon right hand turns around the 120,000 mile mark as if my tire were falling into a pothole that wasn't there. Had one occurrence where a sharp right hand turn resulted into what I'd call a "locked up" steer or loss of steering control and flashing warning light. It then mysteriously resumed normalcy. At 135,000 during a brake job service, mechanic pointed out that the crossmember has prematurely corroded through along with concerns about the subframe and this car was unfit to drive which may be the reason for the above. I'm reading very similar stories of all the same symptoms that have already resulted in accidents with this car which is forcing me to park this.
Engine cradle rusted out. It was replaced and I have the old part. Problem was detected using the vehicle for a short drive at residential speed. If the part had failed on the freeway an accident may have occurred. Vehicle was left at a close by shop who confirmed part failure and warned vehicle could not be driven unless part replaced. Shop confirmed this is not uncommon. Called Ford Motor Company and was told to see my local dealer. Checked with dealer body shop. Body shop said never seen problem before. Parts confirmed common replacement part. Service would neither confirm nor deny quality of original part leading to failure. Concern is for younger drivers for whom this is a family hand me down.
On 8/17/2023 My daughter was on the highway and said she was having a problem after hitting a pothole. I told her to return home. Subframe Broke after hitting a second minor pothole on a side road close to my home. Passenger side tire (fell off?) was turned 90 degrees under the wheel well while the driver side tire was still pointing straight forward. About a 60 foot skid mark dragging the passenger tire at a 90 degree angle until she could pull the vehicle over. If this happened on the highway, I fear the worst would have happened to my daughter. Also, I see that the rear frame is rotted on both sides near the rear shocks.
I had exhaust work done, 2010 Ford Escape, and shop pointed out huge rust hole in ''subframe'' (engine cradle) This has been hundred thousand recalls but NOT all model years, yet they ALL have the same fault. Ford recall only puts a cheap ''brace'' on it but it is NOT a repair!! What kind of country allows these maggots to threaten the driver with complete !! loss of steering control and yet not require repair for faulty frames? They did the half-ass repair on 2001 to 2004 but ALL years up to 2012 have this, and the ''brace '' in cheapo B S.
A/C drain line located above the crossmember(Engine Cradle-#9L8Z-5C145-A) caused it to prematurely rot on the passenger side of the vehicle. Issue was discovered during a routine oil change. Crossmember rot is directly above lower control arm attachment point. In the event of total failure, it would result in loss of control of the vehicle. The driver's side of the crossmember does not have any signs of corrosion.
Had an alternator problem , had vehicle towed to garage for repair. When I picked the owner of the garage there is significant rust to the suspension. I inspected the damage my self and found the "suspension part" that holds the strut was just about rusted through. I researched the web and found out that there were plenty of others who have the same
The complaint is regarding a 2010 Ford Escape, original owner and maintained mostly at dealer shop. Vehicle only has 79k miles on it, and has been garage stored. It has rust in the rear wheel wells and a crack in the rear right subframe due to rust.
Suspension complaints in other Escape years
Frequently asked questions
How common are suspension problems on the 2010 Ford Escape?
NHTSA has 34 complaints about the suspension of the 2010 Ford Escape, 2% of the model year's 2,070 complaints. The component named most often is front (2 mentions).
Is there a recall for 2010 Ford Escape suspension problems?
No. NHTSA lists no suspension recall for the 2010 Ford Escape, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2010 Ford Escape suspension problems start?
Half of the complaints with a recorded mileage happened before about 110,000 miles, and 20% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 0 injuries to suspension problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.