2022 Ford Bronco Sport Engine Problems

Which parts fail

• Cooling system › Pump
  2
• Exhaust system › Emission control › Catalytic convertor
  1

Components named in complaints (engine, cooling system, oil leaks, timing chain, exhaust).

Mileage when the problem started

• Under 25k
  529%
• 25k–50k
  635%
• 50k–75k
  529%
• 75k–100k
  00%
• 100k–150k
  16%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2022 Ford Bronco Sport owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact's daughter owned a 2022 Ford Bronco Sport. The contact stated that an intermittent fuel odor would emit from the vehicle without warning. The contact had inspected the vehicle and did not detect any leaks or defects. The contact stated that while his daughter was stopped in a parking lot, an "engine compartment hot" warning message appeared on the instrument panel as an unknown color smoke began to emit from the vehicle. The vehicle quickly caught fire soon after the smoke began. The fire department arrived at the scene and extinguished the fire. A fire report was filed. The contact's daughter sustained mental anguish as a result of the fire. Due to the failure, the vehicle was towed to an independent tow yard where it remained in their possession for an investigation. The manufacturer was notified of the failure but offered no assistance. The vehicle was destroyed. …

The contact owned a 2022 Ford Bronco Sport. The contact stated that while the son was driving at approximately 60 MPH, smoke was seen coming from under the hood. After driving over to the shoulder and exiting the vehicle, the vehicle was quickly engulfed in flames. The fire department was called to the scene and extinguished the fire. No injuries were reported. During the incident, the vehicle was destroyed and later towed to a nearby towing yard. The cause of the fire was not determined. The manufacturer and dealer were notified of the failure but no assistance was offered. The contact indicated that the vehicle was previously serviced for the NHTSA Campaign Number: 22V859000(Fuel System, Gasoline). The contact indicated that the vehicle had experienced that same failure listed in the recall. No police report was taken. The failure mileage was 6,000.

The contact owns a 2022 Ford Bronco sport. The contact stated while driving at an undisclosed speed, the O2 sensor warning light illuminated. The vehicle was taken to an independent mechanic where the failure was diagnosed with a failed O2 sensor. The contact was informed that the O2 sensor needed to be replaced. The vehicle was not repaired. The contact was informed that the O2 sensor had been ordered. The vehicle was taken to the dealer for an oil change and the contact was informed of a coolant leak. The vehicle was not repaired. The vehicle was driven to the residence. The vehicle was put up on the lift by the contact who is an independent mechanic. The contact performed an inspection of the vehicle and became aware that the coolant pump, catalytic convertor, and serpentine belt had failed. The dealer was made aware of the failure. …

The contact owns a 2022 Ford Bronco Sport. The contact stated that on every occasion while entering the vehicle, there was a fuel odor coming through the vents. The check engine warning light illuminated briefly during one occasion. The vehicle was taken to the same dealer twice and was diagnosed with a cracked coolant pump. The dealer determined that the coolant pump and the purge valve needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was then taken to an independent mechanic, where it was diagnosed and determined that there was fluid leaking nearby the catalytic converter; however, the mechanic was unable to take the catalytic converter apart. The mechanic also determined that the fuel injectors, the exhaust clamps and gaskets, and Oxygen sensors needed to be replaced, and the turbo charger required coolant and oil feed lines replacements. …

I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until it caught fire and electrical smoke was rolling i had to call the fire department i was parked at a dayhab for special needs had to run and have them to remove all of the special needs people in wheelchairs and or with other adaptive equipment had to run into another office building and tell them to remove their vehicles i had a serious worry that this could have hurt or even killed people they at the ford dealer that has had my car 21 days said it's the starter no way the starter just went nuts for no reason we had to call the fire department and everything they replaced the battery which my understanding has recall 24s24 which says causes …

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 22V859000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while accelerating. Additionally, the engine made rattling sounds while driving. Additionally, the brakes failed to stop the vehicle immediately while the brake pedal was depressed. The vehicle also lunged forward while coming to a complete stop. The vehicle was taken to the dealer and Ford Pro Commercial Center (525 N 16th St, Sacramento, CA 95811) on separate occasions; however, the dealers were unable to duplicate the failure. The vehicle was not repaired. …

The contact owns a 2022 Ford Bronco Sport. The contact stated that while depressing the brake pedal to slow for traffic or for a traffic signal, there was an abnormal high-pitched sound coming from the brakes and the vehicle was vibrating. The contact stated no warning light was illuminated. The contact stated that additionally, while driving up a grade in the road, at approximately 35 MPH, the vehicle lost motive power. The contact depressed the accelerator pedal and the vehicle failed to respond as needed. The contact stated that the engine was not revving while depressing the accelerator pedal. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the rear brake rotors needed to be turned. The vehicle was repaired. The contact stated that the failures reoccurred. The manufacturer was not informed of the failure. …

The contact owns a 2022 Ford Bronco Sport. The contact stated that the battery had drained. The vehicle was jump-started. While driving 60 MPH in traffic, the vehicle stalled with several unknown warning lights illuminated. The vehicle was towed to the residence. The contact received notification of NHTSA Campaign Number: 25V019000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer informed the contact that the battery switch was on backorder until September. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 32,691. VIN tool confirms parts not available.

The contact owns a 2022 Ford Bronco Sport. While driving approximately 50 MPH, the contact received an alert indicating that the engine was overheating, with the check engine warning light illuminated. The contact pulled over and became aware that the coolant reservoir was empty. Upon opening the hood, there was white smoke coming from the engine, with a strong coolant odor coming from the vehicle. After adding coolant, the vehicle restarted but only drove a short distance before the coolant leaked out. The vehicle was driven to the residence, where a mobile mechanic inspected the vehicle and determined that it was not repairable and that the engine had cracked from overheating due to the loss of coolant. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

The contact owns a 2022 Ford Bronco Sport. The contact stated that after inspecting the driveway, the contact noticed an abnormal stain on the concrete driveway. The vehicle was taken to a local dealer for routine maintenance and the dealer discovered that the oil filter might have been left loose from the last service performed by the local dealer. The vehicle was repaired; however, the failure persisted. The contact's husband checked under the hood and noticed that oil was leaking onto some hoses. The vehicle was not repaired. In addition, the contact related the failure to NHTSA Campaign Number: 22V191000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.

Related recalls

Engine complaints in other Bronco Sport years