Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Dodge Grand Caravan owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2011 Dodge Grand Caravan. The contact stated that while the vehicle was parked, turned off, and unoccupied, the front driver's side of the vehicle near the driver's door caught fire. The contact extinguished the fire. No fire or police report was filed. The front driver's side of the vehicle was consumed by the fire. The contact believed the failure was due to an electrical malfunction located in the driver's door that caused the fire. The dealer was contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to a salvage facility. The manufacturer was made aware of the failure. The approximate failure mileage was 200,000.
The contact owns a 2011 Dodge Grand Caravan. The contact stated while driving at various speeds, the vehicle stalled without warning. The contact stated that several electrical failures had occurred on the vehicle while the vehicle was turned off. The failures included the sliding doors independently unlocking and opening without warning or input. The contact also stated that the safety alarm would sound independent while the power windows rolled down independently while the vehicle was turned off. The contact had the vehicle towed by a dealer and was informed that the Totally Integrated Power Module (TIPM) was defective and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 160,000. Consumer is still having issues with the vehicle.
The contact owns a 2011 Dodge Grand Caravan. The contact stated that the engine turned over, but the vehicle failed to start. The contact became aware that the jumper ends were burned. There was no fuel entering the engine. The contact stated that the silicon on the relays needed to be replaced and the fuel pump had failed. Additionally, the driver's side window became inoperable. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 19V813000 (Electrical System). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 160,000.
My van caught fire. Randomly after not being driven for more than 15 hours. The investigator says it is believed to be the inverter in the back drivers side panel under the cup holders which short circuited and caught fire which engulfed my entire vehicle in a mater if 40 minutes while waiting for the fire department to arrive. The van is obviously a goner. Burnt to a crisp along with all of our DeWalt power tools batteries fishing poles tackle chainsaw and 4 brand new car seats that were just purchased with the last 2 months. Along with cracking all the windows on that side of my home due to the heat from the blaze...
The contact owns a 2011 Dodge Grand Caravan. The contact stated while driving 45 MPH, the battery warning light illuminated. The contact was able to continue driving to his residence. The contact inspected the vehicle and noticed that the alternator was burned and needed to be replaced. The contact towed the vehicle to the local dealer however, the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 99,938.
Odometer Fraud. The contact stated that while considering purchasing a 2011 Dodge Grand Caravan, the odometer mileage was 101,000 but the registration information indicated that in 2022 the odometer mileage was 125,000. The vehicle was a private sale.
My car was fine until one day in rain the whole dash and radio shut off and came back on repeatedly, spedometer bouncing each time. Took it to dealer/JDByrider and "they dont know prob/happens all the time" w a very "oh well" attitude. They did nothing. I called again when car ALSO started shutting completely off at long red lights. I was told next appt available would be 23 days! Thats still 4 days away. NOW in addition to dash/radio/spedometer problem the van doesnt just die at LONG lights, it dies if I have to stop for drive thrus, stop signs, short lights. The headlights have also started flickering very very badly. Im upset that repairs are supposed to be covered by JDByrider and theyve had me driving this dangerous car for almost a month before trying to fix it. Im not allowed to get work done on it elsewhere or else it makes future repairs on parts not covered by JDByrider. …
This vehicle always fails to start in the colder weather. After a review of this condition. It has been found that the fuel pump relay does not send proper signal. This relay is a part of the Totally Integrated Power Module (TIPM). When it fails to operate, the vehicle will experience long crank times. With its ignition switch style, as soon as you turn the key, the vehicle will continue to crank UNLESS you manually turn the switch all the way back to the off position. This condition will cause the starter motor to overheat or burn up. Eventually the vehicle may start then die. Fuel delivery is too inconsistent when colder weather arises. You can't just replace a plug-in-style replacement fuel pump relay since it is a part of the whole TIPM. This vehicle has not yet died in traffic or on the highway thank God. There is never any CEL illumination or any stored fault codes. …
The TIPM failed which caused a loss of power to the vehicle and power to the fuel pump. I was driving at approximately 60 MPH when the vehicle lost all power and the steering wheel felt locked. I was unable to turn the steering wheel as the Dodge Grand Caravan came to a quick stop as if it was out of gas. Luckily I reacted quickly and was able to avoid an accident. After approximately 10 minutes of trying to restart the vehicle and drive to a safe location the vehicle restarted. This happened again when I was driving and came to a red light at a major intersection and the vehicle stalled out as if out of gas and the steering locked. I again tried to restart the vehicle intermittently for 15 minutes; after which it finally restarted, and I was able to drive and get out of the intersection without an accident. I was lucky that this didn't cause an accident. …
Van has stalled and quit while at intersections and while driving on busy hwy. Have had looked at and seems that the TIPM is the problem. Same as many over vehicles that was recalled for this same reason suck as the Jeep Cherokees. VERY DANGEROUS for it to stall and quit in the middle of traffic, almost been rearended due to the stalling and hit at intersection due to it cutting off completely. Accident wating to happen and have someone be badly injuried or killed. This needs to be addressed and recalled ASAP. Dealership looked at this and stated the same. Please investigate and take correct steps on getting this fixed/recalled before someone is killed.
Related recalls
Electrical system
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014.
NHTSA investigations
Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year.
Electrical complaints in other Grand Caravan years
Frequently asked questions
How common are electrical problems on the 2011 Dodge Grand Caravan?
NHTSA has 332 complaints about the electrical system of the 2011 Dodge Grand Caravan, 63% of the model year's 530 complaints. The component named most often is alternator/generator/regulator (2 mentions).
Is there a recall for 2011 Dodge Grand Caravan electrical problems?
Yes — NHTSA recall 14V-234 (electrical system, May 7, 2014). Recall repairs are free at authorized dealers.
At what mileage do 2011 Dodge Grand Caravan electrical problems start?
Half of the complaints with a recorded mileage happened before about 84,000 miles, and 5% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 13 fires and 4 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.