Seat complaints by model year
Mileage when the problem started
What owners report
Our 2014 Chevy Volt began to rarely give an audible chime with a: "Service Airbag" message on the Driver Information Center display, as well as the "Passenger Airbag" overhead panel display showing "On"-"Off"-"On", spontaneously back in 2018. Again, this was rare, but concerning. This became somewhat more common in the months that followed and is now a common annoyance on every drive. Because of personal circumstances, as well as the Coronavirus Pandemic, we have not driven this vehicle much over the past couple of years, and we have not taken the car in for service. It has not yet been inspected by any other entity other than myself. The alarms happen whether the passenger seat is occupied or not. …
Date above is approximate. The airbag sensor in the passenger side of the vehicle is faulty and causes a constantly cycling alarm when there is a passenger present. I believe this means that it is not accurately sensing the passenger and is turning the airbag on and off, making for a safety issue in the event of a crash. This is apparently a frequent issue and customers should not need to pay the $1,000 to fix the faulty sensor that could put a passenger at risk. https://www.gm-volt.com/threads/2013-passenger-presence-sensor-airbag-error.260945/page-2 https://www.youtube.com/watch?v=gGq_9T6om7g
The passenger presence sensor module has developed a fault. The service airbag soon warning pops up when a front seat passenger gets out of the seat. I can manually recreate the problem by pressing down on the seat bottom cushion and then when I release pressure the warning reappears and then goes away after 10 seconds. I will now need to replace the module and get the vehicle reprogrammed, or find a junkyard seat and hope it doesn't have the same problem. You really should have required GM to do more on this issue when you investigated it! From what I understand, there is not a 'cost reduction program' for having the dealer replace this defective part. This seems to be a very common problem that has perhaps gone underreported, but is obviously going to happen given the design of the sensor pad where it develops a fatigue failure.
The passenger side seat airbag sensor is malfunctioning. A message displaying "Service Airbag" comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now. Starting around 90k miles, currently has 111k miles. I've done my research on this issue and many other Volt owners have this issue. Which is caused by a defect in the passenger side sensor mat in the seat that can fold over itself with normal use, causing the issue.
This issue has been reported extensively: NHTSA PE19013. The passenger seat sensor has failed leading to the airbag turning on and off rapidly while driving. This is available for inspection upon request. I worry about the safety of occupants in the car. If the airbag is turned off despite a passenger sitting in the seat that is a problem. The price of repair at a dealer is very high considering that this is a very clear quality control issue by GM that has been acknowledged by both GM and NHTSA. This warning light has turned on before and then went away for a long time. Now it has returned and after some research it is clearly an issue that many other 2012-2013 volt owners have experienced.
passenger presence detection system is malfunctioning, and causing a "service airbag" warning. This is a huge safety issue that could be detrimental or deathly in the event of an accident. This is a common issue among generation 1 volt owners, and should be considered for a recall or warranty coverage. The passenger presence detection system parts are discontinued, and even if I found the part the dealership cannot confirm for the pricey repair, that the airbag / sensor will not simply malfunction again -- which makes this a persistent safety concern and huge owner inconvenience to say the least.
Frequently asked questions
Which Chevrolet Volt years have seat problems?
By NHTSA complaints, the 2013 (31) and 2012 (14) model years. Seat complaints make up 10% of all complaints for the 2013.
Is there a recall for Chevrolet Volt seat problems?
No. NHTSA lists no seats recall for any Chevrolet Volt model year. A widespread problem may still be covered by an extended warranty or a manufacturer service bulletin, so ask a dealer.
At what mileage do Chevrolet Volt seat problems start?
Across all years, half of the complaints with a recorded mileage happened before about 74,000 miles; 23% happened before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.