Which parts fail
Components named in complaints (headlights, tail lights, turn signals, interior lights).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 Chevrolet Malibu owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving, the brake light was illuminated. The contact stated that at the time she was not depressing the brake pedal. The contact stated that when she was switching gears from either drive or reverse the brake light only illuminates once in gear and does not turn off. The contact also stated that the traction control warning light also illuminates while driving, however the vehicle does not drive any differently. The vehicle was taken to an independent mechanic who advised her that there was a recall on the same year, make and model vehicle as her vehicle NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) . The contact said she was advised that her vehicle had to be taken to the dealer to have her vehicle reprogrammed. …
The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at various speeds, the low-beam headlights failed to properly illuminate the roadway. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where both headlights were replaced. The vehicle was repaired; however, the contact stated that the failure recurred. The vehicle was taken back to the mechanic on two other occasions, where both headlights were replaced. After the repair, the contact stated that she became aware that the passenger's side headlight again failed to properly illuminate. The manufacturer was not made aware of the failure. The approximate failure mileage was 99,000.
The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at various speeds, his headlights would intermittently fail to operate as needed without warning. The contact had taken the vehicle to several independent mechanics and has had multiple headlight bulb replacements; however, the failure still persisted after each repair. The dealer nor the manufacturer had yet to diagnose the cause of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 140,000.
Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is burnt out on bott sides. but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibus and needs a recall initiated to correct these issues. I keep getting pulled over due to need to us high beams and not having low beams. This is reoccurring and getting expensive to be done over and over.
Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is fine but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibu and needs a recall fix.
The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at various speeds and driving over a pothole or an object on the roadway, the front driver's side headlight became inoperable. There was no warning light illuminated. The vehicle was taken to an independent mechanic but was not diagnosed; however, the contact was informed that there was a failure with the electrical wiring inside the front driver's side headlight. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic and was diagnosed and determined that the wiring harness inside the front driver's side headlight needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was unknown.
I bought the car a year ago from a used car lot. Replaced the cam shaft positioning sensor as per diagnostic reading for check engine light. Since then, svc air bag light has stayed on. Traction control light stays on and is disengaged. When braking ESC warning goes on and off and sliding occurs. The low beam headlights go on and off intermittently and no way of knowing when it will happen. When turning cruise control on or off, the car will accelerate on its own and will increase speed until brake is applied. Regardless of whether cruise control was turned on or off. I have had it looked at at my local Mr.Tire and they cannot figure out what is happening.
Passenger side headlamp burned out took off bumper to inspect and the wiring pigtail to the headlight has melted causing it to malfunction so now in order to make it work you have to disconnect the daytime running lights so that the melting stops this is supposedly happened to a lot of Malibu's why there isn't a recall on this fire hazard is beyond me and it is a safety issue cuz you can't use your daytime running lights any longer. This issue has not been reported because upon investigation it's been reported many times and nothing gets done about it you have to pay for it yourself. This will be the last GM product.
I have a 2012 Chevy Malibu i bought it in 2014. I have had the Esc light come on in 2016 but no problem with it untill now of this year in 2022. Not knowing the problem i have already put ALOT into it. I took it to a machanic they told me it was the rack and pinion. So got that done . Apparently it wasn't it took it to another machanic they told me it was struts got that done too n still nothing so i looked it up online got CV joint, inner ,tie rod, wheel alignment. All those done n still nothing fix it. I didn't know what else to do until i made more scratch on my vehicle and i found that it could be a recall .
I bought my chevy Malibu in 2018 from a used car dealership. A couple months after I bought it the radio blew. I tried replacing fuses it would not work. The lights keep blowing. I keep replacing them and have had a new pigtail that's been grounded. That replacement happened last Thursday. Right light has blown again. Short in electrical system. Cause battery to go down. Windows will only work sometimes and the same goes for the door locks. I currently waiting for a tow truck. The new battery will not start.
Headlight complaints in other Malibu years
Frequently asked questions
How common are headlight problems on the 2012 Chevrolet Malibu?
NHTSA has 202 complaints about the lights of the 2012 Chevrolet Malibu, 22% of the model year's 907 complaints. The component named most often is headlights (7 mentions).
Is there a recall for 2012 Chevrolet Malibu headlight problems?
No. NHTSA lists no lights recall for the 2012 Chevrolet Malibu, though it has 2 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 Chevrolet Malibu headlight problems start?
Half of the complaints with a recorded mileage happened before about 100,000 miles, and 7% before 25,000 miles.
Is it dangerous?
Owners linked 4 crashes, 6 fires and 2 injuries to lights problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.