Which parts fail
Components named in complaints (headlights, tail lights, turn signals, interior lights).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Chevrolet Malibu owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2011 Chevrolet Malibu. The contact stated that while the vehicle was parked under a carport in her driveway, she had been warned by neighbors that the rear end of the vehicle was on fire. The contact stated that she saw that flames were issuing from both rear light housings. The contact stated that by the time her husband and a neighbor attempted to extinguish the flames with garden hoses, the light housings and the rear bumper were on fire and melting. The fire department and the police were called. The contact stated that by the time emergency services arrived, the flames had been extinguished. The contact stated that the fire department opened the trunk, and the interior of the trunk and the matting were not damaged. The only damage was to the rear light housings and the rear bumper. The fire department had not issued a report, however the police had. …
The contact owns a 2011 Chevrolet Malibu. The vehicle was previously serviced under NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control). The contact stated that on various occasions while driving at various speeds, the traction control and power steering disengaged independently as the "Reduced Engine Power" warning message was displayed and the vehicle decelerated to 10 MPH. The contact also stated that the brake lights flickered intermittently without depressing the brake pedal. The vehicle was taken to an independent mechanic, where it was diagnosed that the intake camshaft actuator, mass air flow, and manifold absolute pressure (MAP) sensors needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was not made aware of the failure. …
The contact owns a 2011 Chevrolet Malibu. The contact stated that while operating the vehicle, the ESC and traction control warning lights remained illuminated. Additionally, while the cruise control was activated and the brake pedal was depressed, the vehicle unintendedly accelerated. The contact stated that the gear shifter was able to be moved without the brake pedal being depressed. The cause of the failures were not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 122,000.
The contact owns a 2011 Chevrolet Malibu. The contact stated that the front headlights failed to illuminate without warning at start-up. The contact had taken the vehicle to a relative who was able to replace both headlights. Two months after the repair, the passenger's side headlight failed to operate and had the headlight was replaced again by her relative. Despite the replacement of the headlight, the new headlight failed to operate as needed. The contact then purchased a third headlight and the headlight also failed to operate. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 155,000
There was a fire in the trunk on the way to work. Fire department was called to inspect the car and make sure that the fire was out. Fire melted fuse box located in the trunk along with wiring harness and wires, also causing all electrical items to stop working. Claim was attempted to be made, but insurance did not cover this particular issue. After hours of reading as well as watching videos, this seems to be an on problem for Malibu's from 2011-2016. I bought this car one year ago and had a mechanic inspect the vehicle.
Two months ago While driving on the highway at 60 mph at night my headlights shut off with no warning leaving only my running lights, turn signals, brake lights and hazards lights functioning. Neither hi or low beams would function. Yet no warning or service lights appeared on the dash. Local mechanic replaced both the headlights bulbs and connectors on both sides. 3 weeks later it happened again, this time when I started my car the headlights failed to turn on. So i contacted a local Chevy dealer (Rob Eck chevy) who said there was no recall or investigation...so I took it back the mechanic and had him fix it AGAIN. Just a few minutes ago today when I went to go to work yet AGAIN the headlights won't turn on. …
Headlight wiring harness connector has melted multiple times leaving me without low beam headlights while driving at night with my children in the car. This has left me having to use my high beams to drive and this poses as a safety hazard for not only me and my family but other people on the road. This also poses a fire hazard if the plastic connector is getting hot enoughto melt. I have requested warranty replacements for this part through AC Delco and made them aware of the on going problem and informed them that this is a well known issue with this car and that it is extremely dangerous. I have not had the part inspected by a mechanic, insurance company or law enforcement but have the failed part and would be willing to have it inspected by law enforcement or anyone else but can not afford out of pocket expenses to do so. …
I purchased this 2011 Cheverolet Malibu brand new. A few years prior to me giving it to my daughter, I had to get the headlights replaced several times, one would go out a month or so after I had the other one fixed. I gave it to her in 2019 and lately every other week one or even BOTH of the front headlights have gone out. Also, the third brake lamp randomly goes out and now one of the rear brake lamps has gone out. There's already over 100 complaints about these issues with this particular model but GM has yet to do a recall! WHY?? It's clearly an issue with the vehicle and the fact that the ENTIRE front bumper has to come off to get to it is the dumbest thing I've ever seen!!! Headlights, of all things, randomly going out on a vehicle is not safe at all! There are people out here who have children in these faulty vehicles and clearly neither GM nor the NHTSA cares. …
Driverside Airbag light will come on with Service Airbag message. This does occasionally turn off but comes back for days or weeks at a time. Driver side seatbelt light will randomly come on and stay on or turn off. Both airbag and seatbelt light may be on at the same time. If they are all off or the airbag light turns off it's only for a day or two. Most of the time it will be the airbag light only that is on and tends to stay on longer than seatbelt light.
The headlights have went out over 10 times. The wiring keeps burning. This is a known issues. Why is there not a recall? It's extremely expensive and hard to get the front end of the car off to replace the bulb to find out it's not the bulb. It goes out every few months. Even the dealership service department has told me it's a known issue!
Headlight complaints in other Malibu years
Frequently asked questions
How common are headlight problems on the 2011 Chevrolet Malibu?
NHTSA has 130 complaints about the lights of the 2011 Chevrolet Malibu, 13% of the model year's 978 complaints. The component named most often is headlights (4 mentions).
Is there a recall for 2011 Chevrolet Malibu headlight problems?
No. NHTSA lists no lights recall for the 2011 Chevrolet Malibu, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2011 Chevrolet Malibu headlight problems start?
Half of the complaints with a recorded mileage happened before about 104,000 miles, and 5% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 4 fires and 0 injuries to lights problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.