Most common 2005 Chevrolet Corvette Z06 problems
Share of the 5 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Corvette Z06 complaints by model year
Best Corvette Z06 years: 2005. Compare all years →
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2005 Chevrolet Corvette Z06:
Loss of Low Beam Headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning.
Electronic stability control malfunction
On September 17, 2008, odi opened preliminary evaluation pe08-056 to investigate allegations of inappropriate activation of the electronic stability control (ESC) system in model year (my) 2005 and 2006 Chevrolet corvette vehicles.some reports received by odi and some reports to general motors (GM) contained in GM's response to pe08-056 allege that the ESC system malfunctioned causing a sudden and inappropriate…
Simultaneous Loss of Low-Beam Headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both…
Electronic Stability Control
On April 26, 2010, at NHTSA's request following this investigation, General Motors submitted a Defect Information Report to NHTSA to correct a defect associated with the Vehicle Stability Control (VSC) system in approximately 40,000 Model Year (MY) 2005 and 2006 Chevrolet Corvette vehicles (NHTSA Recall No.
What 2005 Chevrolet Corvette Z06 owners say
Body & structure
Tl* the contact owns a 2005 Chevrolet Corvette Z06. While driving 30 MPH, the hard top cover detached from the vehicle. The contact stated that the active handling control for the brakes automatically engaged, which caused the vehicle to crash into a guardrail. The air bags failed to deploy. The contact did not sustain any injuries. A police report was filed. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 90,000. Updated 4/13/15 updated 9/18/2017
Tl* the contact owns a 2005 Chevrolet Corvette Z06. While driving approximately 40 MPH, a loud popping noise was present. The locking mechanism for the roof top malfunctioned, causing the top to eject from the vehicle. During the incident, the passenger in the vehicle suffered a laceration to the face. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.
Frequently asked questions
Is the 2005 Chevrolet Corvette Z06 a good car?
Based on 5 owner complaints filed with NHTSA, the 2005 Corvette Z06 rates better than average: 92% fewer complaints than a typical year of the Corvette Z06 at the same age. It is one of the best Corvette Z06 years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2005 Chevrolet Corvette Z06?
The body & structure — 3 complaints, 60% of all complaints for this model year, most often about body › roof and pillars. Next are the steering (2) and brakes (1).
How many recalls does the 2005 Chevrolet Corvette Z06 have?
NHTSA lists no recalls for the 2005 Chevrolet Corvette Z06. You can still confirm with your VIN using our VIN recall check.
What are the best and worst years of the Chevrolet Corvette Z06?
The best years by complaints, compared at the same age, are 2005. See the full Chevrolet Corvette Z06 years comparison.
At what mileage do 2005 Chevrolet Corvette Z06 problems happen?
The median mileage reported in complaints is about 65,000 miles; 20% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.