Electrical complaints by model year
Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
What owners report
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 55 MPH, the power steering and brakes became inoperable. The driver was able to coast to the side of the road. The check engine warning light was illuminated after the failure. The vehicle was towed to her parent's residence. The vehicle was serviced by an independent mechanic, who stated that the failure was due to the ignition switch. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not covered under the recall. The contact stated that the failure was related to NHTSA Campaign Number: 14V171000 (Electrical System). The failure mileage was approximately 260,000.
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving approximately 30 MPH the fuel indicator began to drop rapidly. The contact stated that he did not notice any warning lights. The contact drove the vehicle to his residence and smelled the odor of fuel and noticed a long streak of fuel, and a puddle of fuel underneath the driver's side door by the rear driver's side tire. The contact observed that the fuel line located under the driver's side of the vehicle had ruptured. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 120,000.
The contact owns a 2009 Chevrolet Cobalt. The contact stated while attempting to start the vehicle, the vehicle failed to start and was jumpstarted; however, the auto theft warning light illuminated, and the key could not be removed from the ignition. The contact was able to drive the vehicle however, the locks failed to lock the doors, and there was a clicking sound when the windows failed to roll up or down. The contact stated that after refueling the vehicle, the vehicle was consuming an excessive amount of fuel. The contact stated that the tank was full however, the next day the fuel tank was empty. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 161,595.
The contact owns a 2009 Chevrolet Cobalt. The contact stated while driving at various speeds, the vehicle would shake, and the vehicle would power off inadvertently. The vehicle would restart however, the steering wheel was difficult to turn. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was informed of the failure. The failure mileage was approximately 134,000.
Our vehicle has had zero accidents the airbag light showed up on dashboard stating check airbags. Then as far as electrical the headlights seem to turn on there own at times. We feel this perhaps is a recall not known yet.
i own a 5-speed manual transmission which should roll freely while in neutral. after starting engine while on a slight incline in a parking lot, the vehicle would not roll in neutral, as if all brakes were being applied. i thought that by driving the vehicle on the road the brakes would free up, but they did not. i shut the engine off and on a few times but that did not make a difference. i could only move forward at 5-10 mph in first gear to get the vehicle home, which fortunately was just 5 blocks away. something smelled terrible like burning wires or brake pads. even after letting the vehicle sit in my driveway for a few hours it would not free up the brakes which were being applied. then i read a tip on an internet users forum: remove a fuse labeled "ABS2" and voila! it freed up the brakes! i can drive the vehicle normally but obviously without ABS capability. …
The contact owns a 2007 Chevrolet Cobalt. The contact's mother stated that while driving at various speeds, the vehicle would stall without warning. The contact stated no warning lights was illuminated. The vehicle was towed to a local dealer where it was diagnosed with needing the ignition switch replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System) however, the VIN was not included. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 107,000.
I was in a crash on 9/19/25 and at the incident none of my airbags deployed. My daily driver for my children and I. I was lucky I was the only passenger at the time. I never expected my airbags not to deploy in a head on crash. The car still sits in my driveway and I have and identical one just like it that I drive! I'd like them evaluated.
Related recalls (1)
Electrical system › Ignition
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the…
Frequently asked questions
Which Chevrolet Cobalt years have electrical problems?
By NHTSA complaints, the 2006 (412), 2005 (323), 2007 (281), 2008 (172) and 2009 (158) model years. Electrical complaints make up 18% of all complaints for the 2006.
Is there a recall for Chevrolet Cobalt electrical problems?
Yes — 1 recall, including 14V-171 (ignition, Apr 10, 2014). Recall repairs are free at authorized dealers; check a specific car with the VIN recall check.
At what mileage do Chevrolet Cobalt electrical problems start?
Across all years, half of the complaints with a recorded mileage happened before about 69,000 miles; 32% happened before 50,000 miles.
What part fails most often?
Owners most often name the ignition (108 mentions), followed by the ignition › switch (53).
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.