Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2006 Chevrolet Cobalt owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact's daughter owns a 2006 Chevrolet Cobalt. The contact stated while driving at various speeds, the power steering failed, and the steering wheel was difficult to turn. Additionally, the door locks would lock and unlock independently, and the speedometer was not functioning properly. The electric power steering warning light was illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.
The contact owns a 2006 Chevrolet Cobalt. The contact stated that while driving at various speeds, the power steering assist failed to operate as the power steering warning light illuminated on the instrument panel. The contact also stated that the speedometer also failed to operate as needed. Neither the dealer nor the manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 200,000.
My headlight an blinker quit working new bulbs an all new wiring it it still will not work My trunk button also just stopped working an the fuse is not blown. I even replaced it just to make sure still nothing. Door panel clips won't stay in bought new ones same thing so now my handle is coming apart an my door doesn't want to shut bc it thinks I'm still holding the handle.. Fuel everytime I get gas I have to crank my car a few times and press on the gas before I can get it to go otherwise it just dies on me I've had it looked at they said it was something about how my car does not know when to stop releasing air I think. My blinkers don't turn off unless I do it manually. The seals on my door is no good anytime it rains it's coming inside of my car an since the door panel won't stay on it's coming straight into my car
The fuel tank has an evap leak that somehow breaks on top the tank so it leaks the gas vapors and could potentially start a fire but the part that breaks is a non serviceable part so it can't be fixed without purchasing a whole new gas tank that isn't cheap. My other concern is the infamous grounding issue with the wires on the ground g105 I believe right next to oil filter that grounds the transmission and engine control modules well it shorts at times when driving and suddenly your car dies while driving how scary it could cause a wreak and kill somebody it's a very scary issue that constantly comes back even after trying to re ground it needs to be recalled and fixed it's going to kill somebody and it's a well known issue for this make and model that should have already gotten attention to be resolved.
While driving the car, it will suddenly stall w the engine running but won't react the use of the brakes, steering or gear shifter. It'll suddenly jerk and the following lights will appear on dash :ABS, Power steering, no brake fluid warning, low fuel warning and check engine. All of the areas have been check and have all their fluids so this doesn't make sense. We bought this car for our 16 year old daughter and the first time she drive it, a truck almost wrecked into her
All of these failed again after repair, the car hes been disabled for over 2 years with the same failures. < Dealer Recalls 14115 Dec 5, 2014 Product Safety - Electric Power Steering Assist 14113C Jul 17, 2014 Product Safety - Replace Ignition Lock Cylinder and Ignition Key 14113 Jul 17, 2014 Product Safety - Replace Ignition Lock Cylinder and Ignition Key
My power steering alert came up and immediately I start having trouble driving as the steering wheel got tight. Almost had a accident and there is other problems with my 2006 chevy cobalt lt that have been on recall and I cannot get any help at local dealership
"Takata recall" on 3/30/18 I was involved in a wreck. I was traveling on a busy city street when the light turned red. I stopped and the person in front of me was driving a large SUV. When the light turned green and traffic began to move I started driving. Out of nowhere with no warning, the driver just stopped and my car ran into the back of the vehicle. We both stayed in our vehicles I called 911. Officers arrived and emergency services. Even though hardly any damage was done to the SUV, my car sustained a lot of damage to the hood and bumper of my car. The airbags didn't deploy. I thought my car was totaled by looking at it. I was able to have most of my car repaired out of pocket because I had liability only at the time. The passenger in front of me after giving information to the responders was able to drive away, I was not. …
The problem that sent it to a different mechanic than the chevy dealer where it came from after a month and 900.00 bill for 550.00 ecm and diagnostic test they did without my permission, there labor for the test and ecm was a total of 900.00. Plus claimed it was throwing a code for a peddle that it needed. We just put a brand new peddle and brand new throttle body on it, it was idled to high, so reason for them getting it was to get the old ecm and new throttle sinked up to reduce the idle , at the time of it leaving me it started and ran just idle to high. Throwing no codes. They got it, claim it wouldn't start so did a diagnostic claimed it needed a new peddle. I said I'm coming to get it, they didn't tell me at any time I couldn't drive it home. I left there lot and pulled about 150 feet off the side of road because it wouldn't shift. Called them , botched did no good. …
Before I get into all of it there has never been an accident not yet at least. I do everything I can to try an stop that from happening, (but accidents do happen) only because I know my car could kill on me so I'm extra careful. 1) After I get gas I'm my car the car won't start right away. I have to restart it a couple times an step in the gas an rev up wasting the gas I just put in to get it to start. 2) When I stop an start to pull out of somewhere on to a main road the car will just die on me so I'm stuck pulling out in traffic trying to get my car to start again. It's when I come to a stop an pull out it just kills on me. …
Related recalls
Electrical system › Ignition
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the…
Electrical complaints in other Cobalt years
Frequently asked questions
How common are electrical problems on the 2006 Chevrolet Cobalt?
NHTSA has 412 complaints about the electrical system of the 2006 Chevrolet Cobalt, 18% of the model year's 2,330 complaints. The component named most often is ignition (34 mentions).
Is there a recall for 2006 Chevrolet Cobalt electrical problems?
Yes — NHTSA recall 14V-171 (ignition, Apr 10, 2014). Recall repairs are free at authorized dealers.
At what mileage do 2006 Chevrolet Cobalt electrical problems start?
Half of the complaints with a recorded mileage happened before about 80,000 miles, and 9% before 25,000 miles.
Is it dangerous?
Owners linked 36 crashes, 6 fires and 122 injuries and 3 deaths to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.