2016 Acura MDX Fuel System Problems

Which parts fail

• Delivery › Fuel pump
  1
• Fuel injection system
  1

Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).

Mileage when the problem started

• Under 25k
  427%
• 25k–50k
  213%
• 50k–75k
  533%
• 75k–100k
  320%
• 100k–150k
  17%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2016 Acura MDX owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2016 Acura MDX. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle hesitated, and the RPM became elevated, before the vehicle accelerated as intended. No warning lights were illuminated. The vehicle was taken to an independent mechanic; however, the failure was not duplicated. The dealer was made aware of the failure. The contact referenced an unknown recall repair with a similar failure; however, the VIN was not associated. The contact was informed that the repair was not associated with the VIN. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 107,256.

The contact owns a 2016 Acura MDX. The contact stated that the vehicle was hesitating and jerking while driving. The emissions and AWD warning lights were illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that there was a fuel leak, and the fuel pump was replaced. After the vehicle was repaired, the contact started smelling an abnormal burning fuel odor. The contact was informed that the connector within the fuel system was corroded and needed to be replaced. The vehicle was repaired. The odor had become progressively worse over time. The vehicle was returned to the dealer who determined that the fuel injectors needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and opened a case of the failure. The failure mileage was 90,000.

Driving home from a trip June 2019 on the highway at 60mph with 3 children and my husband, my 2016 Acura MDX experienced complete engine failure - alarms started to sound and I experienced a loss of acceleration, lights in the dash included Engine Problem, Transmission Problem, Emission System Problem, Critical Failure Detected Stop Driving When Safe etc. The vehicle shifted into neutral. I was able to pull off the road onto the shoulder. The engine was still running but would not shift into park. I contacted Acura TLC to have the vehicle towed but we were stranded on the side of a very busy highway in 90 degree heat with 3 kids waiting. Not only was it unsafe to be driving 60mph and lose engine power, I had to also negotiate three lanes of traffic to safely reach the shoulder. …

Acura MDX 2016 SH-AWD with 113366 miles diagnosis according to warning lights. DTC test certification codes: P0301 Misfire No. 1 cylinder P0306 Misfire No. 6 cylinder P0300 Random Misfire P0420 Catalyst System efficiency below threshold B1 Recommendation was that the Catalytic converter be replaced. All these codes were identified under Honda's TSB 20-100 dated 2/2021 on Odyssey, Pilot and Ridgeline models where AH extended warranty to 10 years from date of purchase or 150K. These V6 engines are pretty close to that of the 2016 MDX. Is there a remote possibility that these DTC codes could exist in MDX V6 engines when an issue arises similar to those in the Honda vehicles? These DTC codes appeared 24 hours/37 miles after a routine oil service on 3/26/2024 at Advantage Acura of Naperville with a perfect inspection report. …

On a multi-day road trip, the car had a temporary complete loss of power on two separate days. Both times this happened after several hours of driving at highway speeds on I-15 in California, outside temperatures were in the 90s. After a slight deceleration and then applying the accelerator again, there was a 'clunk' like sound possibly from the transmission, and then a complete loss of power. The first time I tried to pull over to the breakdown lane, and then regained power after about 2-3 seconds. The second time, we were in the middle of traffic and were not able to pull over, but again after 2-3 seconds, the power came back. The engine did not rev up when applying the accelerator and there were no dashboard lights. This appeared to be either a transmission, fuel delivery, or engine management/drive by wire issue. …

Hi, Vehicle experienced sudden loss of power and inability to accelerate while driving. Engine entered limp mode and would not rev beyond approximately 2,000 RPM. Vehicle became unsafe to operate in traffic due to lack of acceleration. Dealer diagnosed fault code P0087 (fuel rail/system pressure too low) and confirmed failure of the high-pressure fuel pump. Vehicle had hard starting, delayed throttle response, and multiple warning lights related to engine, emissions, and drivetrain systems. This appears to be a fuel system failure affecting vehicle safety. Acura previously issued fuel-system-related recall(s) for similar vehicles, and this failure occurred despite prior recall-related service. Repair cost is approximately $2,400. Failure resulted in loss of engine power and posed a safety risk, especially when attempting to merge or accelerate in traffic. …

We have a 2016 Acura MDX and it has automatically shifted to Neutral 3 times (twice while driving on the freeway and 1x yesterday while driving on the street at normal speeds) in the last 2 months. On the MDX dashboard, it will display "Emissions System Problem" and then display "Stop Driving When Safe. Transmission Problem. See Manual." However, the car will automatically shift to Neutral within seconds. My children's lives (7 y/o and 5 y/o) were placed in danger as a result of this system failure. I have contacted the Acura Honda Recall Specialists and Client Relations Representatives. The car is being diagnosed at Cerritos Acura dealership at the present time. A case number has been filed since our VIN shows no recall, despite it having recalls for other 2016 Acura MDXs.

My vehicle is showing the exact same symptoms that the 2016-2018 MDX fuel pump recall is stating but my VIN number is not part of the vehicles being recalled. I reached out to Acura relations and unfortunately, they cannot provide authorization to repair my fuel pump even though my vehicle falls under the same years that this model is being recalled for. I went to an independent shop to try and understand what the problem with my vehicle is and I was told that the high pressure fuel pump seems to be failing and was asked why I have not taken the vehicle to the dealership for the fuel pump recall. Due to this issue I am unable to properly use my vehicle. If i step on the accelerator too hard, the vehicle gets engine misfires and immediately goes on limp mode.

My mechanic replaced the battery on May 9th and could smell gas but I had just fueled the vehicle. Two days later is when it got worse while driving back home I pulled over and could smell gasoline inside the vehicle as if an open gas can was sitting in the passenger seat. I stopped using the vehicle and took it to my mechanic and he discovered a crack in the weld on the front fuel rail. This could have harmed my family, pets or myself if it had caught on fire. In 1 hour I used a quarter tank of gas because of the high pressure pushing the gas on to the engine. Vehicle taken to Anchorage Acura and the Acura mechanic confirmed what my mechanic found. There were no warning lights or indications of anything wrong until I could smell the gas.

"Emissions system problem" warning light has lit up on dashboard twice. This was checked and found to be a faulty code both times however, the second time it occurred, it correlated with the sway bars needing to be replaced.

Related recalls

Fuel System complaints in other MDX years