Most common 2000 Volvo WG problems
Share of the 2 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Volvo WG complaints by model year
Best WG years: 1995, 1996, 1997. Compare all years →
2000 Volvo WG recalls (5)
Exterior lighting › Tail lights › Switch
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the two tail lamps, back-up lamp,and license tag lamp were mounted on insufficiently rigid mounts.
Remedy: Dealers will attach the two tail lamps, back-up lamp, and the license tap lamp on stiffer brackets. Owner notification began October 31, 2002.
Steering › Linkages › Tie rod assembly
On some heavy duty class 8 vehicles equipped with arvinmeritor axle assemblies which May have been manufactured with trw model 20edl ball sockets, the tie rod ball-socket bearings have a below specification case depth and/or hardness which can lead to premature wear out of the socket in some applications.
Remedy: Dealers will replace the ball socket assemblies. This campaign supersedes NHTSA campaign nos. 01v-139.001 and 02v-037.002. Owner notification began July 25, 2002.
Suspension
Vehicle description: heavy duty 6x4 trucks equipped with chalmers 800 series suspension kits. These suspension kits May have insufficient penetration of the weld attaching the torque rod eye to the torque rod tube.
Remedy: Dealers will replace all chalmers fixed torque rods on these vehicles. Chalmers is conducting the owner notification and remedy for this campaign.
Wheels › Rim
Vehicle description: heavy duty trucks equipped with accuride 22.5 x 8.25 15 tubeless demountable rims, part no. 32051. Certain rims contain a non-fusion area in the butt-weld of the mounting ring. Under certain circumstances, the defect could develop into a crack on the mounting ring.
Remedy: Accuride will inspect and replace the defective or suspect wheel rims.
Service brakes, air › Antilock
Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of…
Remedy: Dealers will replace the ABS ECU.
Frequently asked questions
Is the 2000 Volvo WG a good car?
Based on 2 owner complaints filed with NHTSA, the 2000 WG rates few complaints: 2.0× as many complaints as a typical year of the WG at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2000 Volvo WG?
The wheels & tires — 1 complaint, 50% of all complaints for this model year, most often about lugs/nuts/bolts/studs. Next is the steering (1).
How many recalls does the 2000 Volvo WG have?
There are 5 recalls for the 2000 Volvo WG, the most recent from September 9, 2002 (switch). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Volvo WG?
The best years by complaints, compared at the same age, are 1995, 1996 and 1997. See the full Volvo WG years comparison.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.