Most common 2000 Volvo VN610 problems
Share of the 18 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Volvo VN610 complaints by model year
Best VN610 years: 2000, 1999. Years to avoid: 1998. Compare all years →
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2000 Volvo VN610:
Steering axle u-bolt
Steering gearbox or u-joint
Sleeper berth fires
Front suspension u-bolts loosen or break
Odi'sinvestigation did not find any evidence that loose or brokenfront suspension u-bolts have caused or contributed to any crashes or near miss events.see the attached engineering analysisreport for full technical details.* 1996/1997 built vehicles are designated by Volvo as 1998 model year.
What 2000 Volvo VN610 owners say
Suspension
The truck shakes and makes popping noise when stopping, consumer states that the front springs failed and the dealer agreed to replace it under warranty, however Volvo will not upgrade to a heavy duty spring.
Consumer stated that he has replaced 4 sets of steer axle tires, due to vehicle being out of alignment, also vehicle was experiencing vibration.
Electrical system
Consumer states vehicle has experienced shorts, blowing fuses in dash and column.
Steering
While driving 55 MPH on the highway a malfunction occurred within the steering gear box which caused the vehicle to jerk and then pull to the left, causing loss of vehicle control, which resulted in a collision. Please give any further details.
Consumer states experiencing problems with the steering gear box.
Frequently asked questions
Is the 2000 Volvo VN610 a good car?
Based on 18 owner complaints filed with NHTSA, the 2000 VN610 rates better than average: 52% fewer complaints than a typical year of the VN610 at the same age. It is one of the best VN610 years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2000 Volvo VN610?
The suspension — 7 complaints, 39% of all complaints for this model year, most often about front › hub. Next are the electrical system (3) and steering (3).
How many recalls does the 2000 Volvo VN610 have?
NHTSA lists no recalls for the 2000 Volvo VN610. You can still confirm with your VIN using our VIN recall check.
What are the best and worst years of the Volvo VN610?
The best years by complaints, compared at the same age, are 2000 and 1999. Years to avoid or approach with caution: 1998. See the full Volvo VN610 years comparison.
At what mileage do 2000 Volvo VN610 problems happen?
The median mileage reported in complaints is about 489,000 miles; 0% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.