Volvo VHD complaints by model year
2021 Volvo VHD recalls (6)
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Seats › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly…
Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Wheels › Hub
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.
Remedy: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.
Service brakes, hydraulic › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling 2021 VNL, VNR, VAH, and VHD vehicles. The collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing.
Remedy: Volvo Trucks will notify owners, and dealers will inspect the air brake line for proper engagement of the fitting in the pass-through plate, free of charge. The recall is expected to begin January 31, 2021.
Service brakes, air
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VAH, VHD, VNL and VNR vehicles. The die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the pedal plates if required, free of charge. The recall began October 7, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2021 VNL, VHD, and VNR vehicles. The king pin nut may not have been installed or properly tightened during axle assembly.
Remedy: Volvo Trucks will notify owners, and dealers will inspect the vehicle to make sure that the king pin nut is installed and that it properly tightened, free of charge. The recall began September 28, 2020.
Frequently asked questions
How many recalls does the 2021 Volvo VHD have?
There are 6 recalls for the 2021 Volvo VHD, the most recent from October 23, 2024 (software). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.