Volvo Acl complaints by model year
1997 Volvo Acl recalls (6)
Service brakes, air › Antilock
Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of…
Remedy: Dealers will replace the ABS ECU.
Parking brake
Vehicle description: heavy duty trucks equipped with haldex manifold dash valves (mdv) used in tractor and trailer parking brakes. These valves do not meet the requirements of FMVSS no.
Remedy: Dealers will replace the suspect valves.
Steering › Linkages
Vehicle description: heavy duty trucks equipped with a fal 8.0 front steer axle. The upper steering arm can fail without warning.
Remedy: Dealers will inspect the upper steering arm and replace it, if required.
Suspension › Front › Springs › Air suspension › Lines and fittings
Vehicle description: class 8 heavy duty trucks. The air suspension control valve supply line was not plumbed through an air pressure protection valve. In the event of a failure, there would be loss of air pressure in the 'b' system air reservoir that supplies air pressure for the front steer axle brakes.
Remedy: Dealers will install the necessary air pressure protection valve.
Wheels › Rim
Vehicle description: heavy duty trucks equipped with aftermarket aluminum dual wheels, 22.5x8.25, one-piece, tubeless, supplied by accuride/akw. Certain design revisions combined with process conditions caused fatigue cracks in these wheels.
Remedy: Accuride/akw will replace these wheels.
Suspension › Front › Wheel bearing
Vehicle description: class 8 heavy duty trucks. The steer axle wheel bearing jam nut lock washer May not have been bent over the jam nut after the wheel bearings were adjusted.
Remedy: Dealers will inspect the steering axle wheel bearing jam nut lock washer to determine if it is bent over the jam nut, and if not, repair as required.
Frequently asked questions
How many recalls does the 1997 Volvo Acl have?
There are 6 recalls for the 1997 Volvo Acl, the most recent from August 22, 2000 (antilock). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.