Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2021 Volkswagen Tiguan owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving approximately 55 MPH, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The contact stated that on three separate occasions, while the vehicle was parked, the contact observed oil on the ground underneath the vehicle. The vehicle was then taken to a dealer, and oil was discovered under the vehicle. The vehicle was diagnosed, and determined that the breather failure caused the crank case pressure to enter the system, causing the upper timing gasket and seal to be compromised and leak oil. The contact was informed that the oil separator timing cover, CAM magnets, and oil pan needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
The contact owns a 2021 Volkswagen Tiguan. The contact stated while driving 65 MPH, the accelerator pedal was depressed, and the vehicle failed to respond. The contact stated that the vehicle was losing power and was unable to drive uphill. The contact also stated the engine was consuming an excessive amount of oil; however, the dealer had informed her that the oil consumption was normal. The check engine and electronic power control (EPC) warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the turbo cylinder and timing chain needed to be replaced. The local dealer was contacted; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.
The contact owns a 2021 Volkswagen Tiguan. The contact stated that the vehicle was leaking oil. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the valve cover needed to be replaced. The vehicle was repaired, but the failure recurred. There was gray smoke coming from the vehicle. The vehicle was taken back to the local dealer, where it was diagnosed that the valve stem seals needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 53,000. The VIN was not available.
The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive. The low oil level warning light was illuminated. The vehicle was towed to an independent mechanic, who observed a crack in the oil pan. The vehicle was repaired, but the failure reoccurred. The vehicle was towed back to the independent mechanic, who then diagnosed a failure with the engine. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 50,000. The VIN was not available.
The contact owns a 2021 Volkswagen Tiguan. The contact stated while driving at an undisclosed speed, the contact noticed blue smoke coming out of the exhaust pipe. There was no warning light illuminated. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 46,000.
Vehicle was just turned on and put into reverse. Dash and infotainment center lights flashed and shut off. Vehicle rolled backwards uncontrollably down a sloped driveway. Steering and brakes were not properly functioning. Vehicle came to a stop when it struck a parked vehicle in its path.
Engine oil light came on and car was down about 2 quarts of oil AGAIN. Car was last serviced as noted below VW service 11/22/2024 Mileage in 62086 Mileage out 62087 (what kind of test drive was this, less than a mile) ?? 2021 VW Tiguan Service Advisor 413 Montpelier VW 802-223 -3434 ____________________________________________________________ A C/S: Check Engine light is no CEL Default 1000 CP606.33 1.1 06M-906-517-E VALVE 32.67 2.1 06Q-103-495-B SEPARATOR 93.74 3.2 06l-103-583-C GASKET130.06 4.1 06L-103-483-a GASKET 77.20 PARTS: 333.67 LABOR: 606.33 OTHER: 00.00 TOTAL line A $940.00 620000 P04F000; EVAP system high pressure purge line performance Checked purge valve and found oil in line, due to a defective crankcase breather and causing an oil leak, replaced crankcase breather, replaced the EVAP purge valve and replaced the upper timing cover gaskets, cleared code cleaned oil off …
Upon starting my 2021 Volkswagen Tiguan, the vehicle immediately went into "limp" mode and the check engine light and EPC light came on. The vehicle would not drive over 18 mph. The car was towed to a close by Volkswagen dealership and checked for codes using a multipoint inspection. The report came back with a throttle body issue (Multipoint inspection report attached). The throttle body was replaced and the vehicle was taken for a 15 mile test drive. During the drive, the same problem occurred. After the drive, 34 codes were found in VWs report. I have also attached the report to this complaint. The technicians at the VW dealership didn't understand the problem, so they opened up communication with Volkswagen in Germany. The Volkswagen engineer advised the dealership to replace the wire harness. …
Subject: Complaint Regarding 2021 Volkswagen Tiguan - Premature Engine Failure at 46,000 Miles To Whom It May Concern, I am filing a complaint regarding my 2021 Volkswagen Tiguan (VIN: [redacted] ) which suffered a catastrophic engine failure at only 46,000 miles. I purchased the vehicle used in August 2023 through CarMax Auto Finance. At the time of failure, the car had fewer than 50,000 miles and had been properly maintained. Despite the extremely low mileage, Volkswagen has refused to cover the repair under warranty because the vehicle is slightly past the 4-year time limit. I believe this is unfair and unreasonable. A major component such as the engine should not fail this early, and a vehicle sold under these conditions is not fit for its ordinary purpose. Because of this premature failure, I was left with no functional car but still obligated to pay the outstanding loan balance. …
2021 Volkswagen Tiguan, Approximately 40,000 miles Date of failure: Oct 12th, 2025 Component(s): Engine, Powertrain, Vehicle Speed Control, Throttle body Description of the problem: My 2021 Volkswagen Tiguan experienced a complete engine failure despite having multiple prior service visits for engine-related issues while it was still under warranty. During the warranty period, I brought the vehicle to Grand Junction Volkswagen (Grand Junction, CO) several times for problems including: * Excessive oil consumption * "Check coolant" warning light turning on * EPC (Engine Power Control) mode activating and loss of power The dealership performed an oil consumption test and told me the results were "normal," but they did not address the coolant light or EPC issues, stating these conditions were within normal limits. The same problems continued after each visit. …
Engine complaints in other Tiguan years
Frequently asked questions
How common are engine problems on the 2021 Volkswagen Tiguan?
NHTSA has 57 complaints about the engine & cooling of the 2021 Volkswagen Tiguan, 40% of the model year's 143 complaints.
Is there a recall for 2021 Volkswagen Tiguan engine problems?
No. NHTSA lists no engine & cooling recall for the 2021 Volkswagen Tiguan, though it has 5 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2021 Volkswagen Tiguan engine problems start?
Half of the complaints with a recorded mileage happened before about 53,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to engine & cooling problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.