2023 Volkswagen Taos Engine Problems

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2023 Volkswagen Taos owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2023 Volkswagen Taos. The contact stated while driving 45 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The ETC (Electronic Throttle Control) warning light illuminated. In addition, the engine revved independently. The vehicle was taken to the dealer where it was diagnosed that the cam shaft timing had failed. The timing belt and cam magnet were replaced. The contact stated that on a separate occasion, while driving 45 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal and the engine revved independently. The ETC warning light illuminated. The vehicle was taken back to the dealer and was diagnosed that the cam shaft sensor had failed. The vehicle was repaired. The contact stated that recently the vehicle failed to accelerate as intended while depressing the accelerator pedal. …

The contact owns a 2023 Volkswagen Taos. The contact stated that while operating the vehicle, the check engine warning light illuminated. The vehicle was taken to the local dealer, who diagnosed that there was coolant intrusion into the head gasket. The head gasket was replaced, and the vehicle was repaired. Later, while driving 55 MPH, the message "Transmission Failure" was displayed and the transmission shifted to D2, causing the vehicle to decelerate to 25 MPH. The vehicle was parked, and after restarting the vehicle, the vehicle operated normally. The vehicle was later taken to the local dealer, who diagnosed that the Medtronic transmission had failed and needed to be replaced; however, parts were on back order. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 10,185.

Purchased a 2023 VW Taos SE on December 21st, 2022, with 11 miles on it. The first check engine light came on the end of January 2023 and it started having the acceleration lagging issue right before that. Dealer said it was a fuel issue and fixed it. Second check engine light was in March, dealer said to not top off the gas when pumping and fixed it. Third check engine light came on in April and VW Corporate's Service team got involved, claimed it was an emissions issue and fixed it. This entire time, the acceleration lagging issue continued sporadically. To the point you would have to floor the accelerator to get it to move, especially when changing lanes in traffic. Which a 2-3 second delay is dangerous! I had a car behind me honk, because the Taos was not accelerating. No matter what the dealer did to fix it, it did not work. …

Two months ago I noticed an issue with my 2023 VW Taos. VW topped off the fluids and told me to stop back in if it happened again. Three weeks later I was 200 miles from home and it happened again. I stopped in another VW dealer and they topped off the fluids and said if it happened again to bring it in. Today, December 15, 2023 I take my vehicle to the VW dealer with ~22,000 miles and the service advisor and mechanic come over to me and said "we are not allowing you to leave in your car today". I asked why and they said the head gasket is gone and the engine needs to be taken apart. They said corporate requires pictures of this because it is a known problem with this engine between 20K and 30K miles the engine head gasket cracks, coolant light enables, and the engine can blow. …

I bought this vehicle in April of 2023, brand new with 300 miles on it. The dealership then sold to a different dealership in June of 2023. In November/December of 2023, a light on my dash came on saying that my antifreeze was low. I opened up the hood and there was absolutely NO antifreeze in it. I called my dealership, they couldn't get me in until January 2024. So I filled it up with antifreeze and made it to my appointment in early January. The dealership told me that my previous dealership hadn't filled up my antifreeze all the way and that I had just burned that much since April. They topped it off and "checked all the lines". Then in April of 2024, the antifreeze light came on AGAIN. Not even 4 months later. I go check and AGAIN my antifreeze is completely EMPTY. NOT EVEN 4 MONTHS LATER! So I call the dealership and tell them what's going on. …

2023 VW Taos leased in June 2023 - needed to replace brakes 2 years (June 2025) into owning the car. Inspection would not pass without them. This is an excessively quick wear that cost me over $600 for a leased vehicle that should be just basic ownership during 3 year lease. August 2025 - Brought in for an oil change and a coolant yellow light on dashboard. Our local mechanic would not touch the coolant issue as he said it seems to be related to a head gasket leak. The 2022 model had many issues with this problem, however no issues are reported on the 2023 Taos. I have had to find another vehicle to drive and wait 5 days to get it into our local VW dealership, who told us it was OK to drive without even looking at the vehicle. No thank you! We called VW and if in fact this is a head gasket, it would be covered under warranty. …

The vehicle begins to feel like it is skipping while driving. The EPC light comes on, the dashboard beeps and indicates lane assist is unavailable, check engine sign illuminates. The vehicle will drive for a short time but then jerks and just stops. This has happened at least 3 times. Dealer has already replaced the fuel pump, electrical wiring and some switch that wasn't readying properly. After the fuel pump was replaced, the tank was filled, continue to track down miles and gallons. When the vehicle got to 135 travel miles left and one notch above the gas tank, it jerked and stopped immediately at an unsafe spot on the road. The sensor was not properly reading the gas and the tank was empty! This last incident was the same evening after an inspection and 60K service. This vehicle is unsafe and VW should be making this right. …

On April 27, 2025, in [redacted] , the vehicle displayed a low coolant warning in the morning. The owner replenished the coolant as instructed, the warning cleared, and the vehicle was driven to work without incident. Later that day, while traveling southbound on [redacted] at approximately 60 mph, the engine overheat warning activated, forcing the driver to stop and pull over. The vehicle required two separate tows - first to the residence, then to the dealership the following day. On April 30, 2025, the dealership completed a full warranty repair replacing the engine head gasket and seals under TSB 2071245/1, a Volkswagen-issued Technical Service Bulletin acknowledging a known manufacturing defect in the 2022-2023 Taos cooling system, for which there is no recall issued. A formal case was opened with VW Customer Care prior to the repair visit and is on record. …

While driving Dec 10, 2024 my VW Taos failed to accelerate after slowing at an intersection. If this happens when I'm turning, on coming traffic has to slow down unexpectedly. The EPC light and check engine light came on. Car would not go above 15-20 mph. Called dealer and cautiously drove car to dealer. The mechanic said a popped fuse was reason the lights came on and car wouldn't accelerate. They replaced 10A fuse and said codes/lights corrected. Now on 12/23/24 same exact issue has occurred. This is a huge safety concern. Taos 2022 models had a safety recall for a fuel delivery module that was causing that exact same issues and EPC and check engine light to come on. I am waiting for the dealer to call me back now to discuss how serious this really is and to get them to acknowledge they didn't truly diagnose the vehicle the first time (given the 2022 Taos safety recall). …

This vehicle has a known design flaw which causes the cylinder gasket to leak and require replacement. VW has only issued a Technical Service Notice which was no provided to owners regarding the part that needed replacement. They are correcting the problem with a differently designed part in order to try to cure the design flaw. This can cause catastrophic engine failure. It should have been a recall. I should have been notified and the car should have been repaired at VW's expense. They have explained since your agency didn't issue a recall, they dot need to inform the public. Now they are expecting me to pay $3000 to correct their design error and also pay for rental car while it is under repair. This is a major violation of the lemon law, and yet there are numerous verified complaints. …

Engine complaints in other Taos years