Most common 2003 Volkswagen Passat problems
Share of the 631 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Volkswagen Passat complaints by model year
Best Passat years: 2011, 2019, 2020. Years to avoid: 2013, 2014, 2012, 1999, 2002. Compare all years →
2003 Volkswagen Passat recalls (6)
Air bags › Frontal › Driver side › Inflator module
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298.
Fuel system, gasoline › Delivery
Volkswagen is recalling 412,000 my 1999-2005 passat (5th generation) vehicles equipped with automatic transmissions and produced after June 14, 1999. These vehicles May have an underbody heat shield that can become damaged.
Remedy: Dealers will install additional underbody heat shields on vehicles with automatic transmissions to cover the possibly damaged areas and flash all 1.8t engines with a precautionary software update.
Fuel system, gasoline › Delivery › Fuel pump
On certain vehicles equipped with 1.8l turbo, 2.8l v6, or 3.0l engines, a change in the electrical motor components in the fuel pump can lead to an inoperative fuel pump and, ultimately, stoppage of fuel supply to the engine causing it to stall.
Remedy: Dealers will install new fuel pumps free of charge. The recall began on September 28, 20007. Owners May contact vw at 1-800-222-8987 or Audi at 1-800-822-2834.
Exterior lighting › Brake lights › Switch
On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch May malfunction if it was installed incorrectly.
Remedy: Dealers will install the newly designed brake light switch free of charge. The recall began on April 27, 2007, and will be conducted in several staggered mailings through September 21, 2007.
Fuel system, gasoline › Delivery › Fuel pump
On certain vehicles produced from September 2002 - March 2003, equipped with 1.8l turbo, 2.8l v6, or 3.0l engines, a change in the electrical motor components in the fuel pump can lead to an inoperative fuel pump and, ultimately, stoppage of fuel supply to the engine causing it to stall.
Remedy: Dealers will install new fuel pumps free of charge. The recall began on April 10, 2006. Owners May contact vw at 1-800-222-8987 or Audi at 1-800-822-2834.
Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap
On some passenger vehicles, the fuel tank filler neck can suffer abrasion damage if the rear tire goes flat and the vehicle is driven until the tire disintegrates.
Remedy: Dealers will fit passat vehicles with a new wheel house liner that will better protect the car's filler neck. Jetta vehicles will be fitted with a different metal shield designed to enhance abrasion protection in the…
NHTSA defect investigations
Federal safety investigators have looked into 6 possible defects involving the 2003 Volkswagen Passat:
Engine Compartment Fire
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s).
Fuel tank leak
Volkswagen (vw) is recalling certain vw passat 4motion and Audi a6 quattro and allroad quattro all-wheel drive passenger cars.vw vehicles subject to recall were manufactured from November 22, 2000 through May 31, 2005 and Audi vehicles subject to recall were manufactured from June 2, 2001 to June 1, 2005.the NHTSA recall number for the vw vehicles is 08v-156 (vw also is correcting defects related to heat shield and…
Passenger/engine compartment fires
Many of the fire reports allege that the vehicle fire was attributed to ignition coil failure.vw provided additional data regarding its analysis of vehicle fires and a detailed description of the three different engines and ignition systems for the subject vehicles.odifinds the need to further investigate this issue.to facilitate acquisition and analysis of additional information, this investigationhas been upgraded…
Engine Compartment Fire
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports…
Passenger engine compartment fires
The manufacturer notified NHTSA on 04-apr-08 that a safety recall action would be initiated to remedy the issue.in June 2008, the manufacturer issued a technical service bulletin (code 26e5/r5) regarding the specific procedures to be employed in this campaign.vehicle owner notification letters were sent beginning approximately June 13, 2008.the campaign was assigned NHTSA no.
Engine stalling
By letter received on June 24, 2005, mr. Ronald m. Strickland of raleigh, nc, submitted a petition requesting that the agency investigate the performance of the ignition coil plugs on model year (my) 2000-2003 Volkswagen jetta, golf and passat sedans.the petitioner alleges that he had experienced multiple stalling events as a result of one or more ignition coil plugs malfunctioning on his 2002 vw jetta sedan.as a…
What 2003 Volkswagen Passat owners say
Fuel & propulsion system all 171 →
The contact owns a 2003 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The manufacturer was made aware of the failure and informed the contact that the parts needed for the repair could not be found. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 07V375000 (Fuel System, Gasoline); however, the VIN was included but the vehicle was not repaired. The failure mileage was approximately 133,000.
Vehicle has major fuel pump issue, currently at 132,000 and noticing loss of power, car shaking, and occasional stall. A code reader is unable able to detect the issue which is a major concern. I have contacted the volkswagen Manufacturer and I consistently keep getting ignored after bringing up the recall that was put out for the fuel pump. While driving on the highway my rear and front suspension failed and dropped suddenly while moving slowly during traffic. I whave only been able to repair the front shocks and struts so far, but the rear are needed as well. I would like to state that all the parts are original manufacturer parts.
Engine & cooling all 153 →
The contact owns a 2003 Volkswagen Passat. The contact stated that while driving approximately 35 mph the vehicle's speed suddenly begin to reduce and smoke was present coming from the engine compartment. After stopping and exiting the vehicle became engulfed in flames. The fire department was called to the scene and extinguished the flames and the vehicle was towed away. During the incident, the vehicle was destroyed. The local dealer and manufacturer were notified of the incident but no assistance was offered. The failure mileage was 150,000.
The contact owns a 2003 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, coolant leaked onto the front passenger's side floorboard. The contact stated that the coolant leak was underneath the glove compartment area. The vehicle was taken to an independent mechanic, and the contact was advised to have the vehicle taken to the Volkswagen dealer. The contact visited the dealer and discussed the reoccurring failure and was informed that the heater coil was designed incorrectly, and the failure was due to the design of the heater coil. The contact was informed that the heater coil needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 72,000.
Electrical system all 91 →
My front driver seat warmer was turned on low. I could feel the seat getting warmer and checked to be sure the setting was not on high which it wasn't. I thought maybe I was being sensitive and stuck my mitten under my thigh. I then noticed a funny smell and suddenly things got very hot and started to burn my leg as I was driving. I looked down and actually started to see smoke. I was not able to just pull over but quickly turned the seat off. I pulled out my mitten and fleece was actually melted. I was a block or two from work and tried to keep from sitting completely down as it burned. I arrived and jumped out to see a blackened area and hole in my seat!! The car was smelling and I am still in shock over this. I have looked and can't find a recall on the seat. This is very disturbing and dangerous. This should not happen no matter how old the car is.
On April 20, 2010 my 2003 Volkswagen passats check engine light came on at around 4:45 pm. I immediately called the place who does all my repair work, and was told I could drop off the car that night, and they would check it out the following morning. I arrived at the location around 5:10, parked the car and went to place my key in the night drop box. When I walked back to the car I saw smoke coming out from under the hood. I raised the hood and saw flames coming from what looked like under the back of the engine compartment. Then I noticed that there were flames coming out from under the dashboard inside the car. I called 911 and ran to a nearby gas station to get a fire extinguisher. When I got back to the car there were flames visible inside the car. I used the entire fire extinguisher and it did not even phase the fire. Within 1 minute the entire car was engulfed in flames. …
2003 Volkswagen Passat engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.8L 4-cyl turbo | 5-speed manual | FWD | 19 / 28 / 23 |
| 1.8L 4-cyl turbo | 5-speed automatic | FWD | 19 / 28 / 22 |
| 2.8L 6-cyl | 5-speed manual | FWD | 17 / 26 / 20 |
| 2.8L 6-cyl | 5-speed automatic | FWD | 17 / 25 / 20 |
| 2.8L 6-cyl | 5-speed automatic | 4WD/AWD | 17 / 24 / 19 |
| 4.0L 8-cyl | 5-speed automatic | 4WD/AWD | 16 / 23 / 18 |
| 4.0L 8-cyl | 6-speed manual | 4WD/AWD | 15 / 22 / 18 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2003 Volkswagen Passat a good car?
Based on 631 owner complaints filed with NHTSA, the 2003 Passat rates avoid: 3.1× as many complaints as a typical year of the Passat at the same age. It is one of the Passat years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2003 Volkswagen Passat?
The fuel & propulsion system — 171 complaints, 27% of all complaints for this model year, most often about delivery › fuel pump. Next are the engine & cooling (153) and electrical system (91).
How many recalls does the 2003 Volkswagen Passat have?
There are 6 recalls for the 2003 Volkswagen Passat, the most recent from June 13, 2018 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Volkswagen Passat?
The best years by complaints, compared at the same age, are 2011, 2019 and 2020. Years to avoid or approach with caution: 2013, 2014, 2012, 1999 and 2002. See the full Volkswagen Passat years comparison.
At what mileage do 2003 Volkswagen Passat problems happen?
The median mileage reported in complaints is about 59,000 miles; 40% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.