Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Toyota Highlander owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2019 Toyota Highlander. The contact stated that while reversing out of a driveway, the vehicle began to jerk without warning. Once the contact reached the base of her driveway, the vehicle accelerated backward into a neighbor's tree. The air bags did not deploy upon impact. The contact called the ambulance where her daughter was transported to a hospital after she suffered a gash to the back of her head due to the accident. The contact and her daughter's friend both suffered whiplash as a result of the accident. A police report was filed. The contact was able to drive the vehicle back into her driveway where it remained in her possession. The contact called the dealer to check for recalls and was informed that there were zero recalls on the vehicle. The manufacturer had yet to be notified about the failure. The vehicle had to be repaired. …
The contact owns a 2019 Toyota Highlander. The contact stated that while driving approximately 30 MPH, the vehicle stalled; the contact shifted the vehicle into park(P) and restarted the vehicle for the vehicle to return to normal operation. No warning lights were illuminated; however, the "Auto START/STOP Failure" and "See Dealer" messages were displayed on the instrument panel. The failure reoccurred on several occasions. The vehicle was taken to a dealer, where it was diagnosed, and determined that the wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 86,530.
The contact owns a 2019 Toyota Highlander. The contact stated that while the vehicle was parked and attempting to start the vehicle, the vehicle failed to respond as intended. The contact stated that the failure had been recurring, and the battery was replaced, as recommended by the local dealer; however, the failure persisted. The vehicle was taken to another local dealer where it was diagnosed that the START/STOP system was draining the battery. As a result of the failure, the START/STOP system was turned off. The manufacturer was made aware of the failure and referred contact to the NHTSA Hotline for assistance. The failure mileage was approximately 77,000.
I was involved in an accident that I believe was caused by sudden unintended acceleration (sua). In a very busy commercial parking lot, I was pulling into a parking space proceeding at a very slow speed, when there was a sudden surge in acceleration accompanied by a grinding/acceleration sound. I hit the brake to no effect, and the vehicle jumped the curb and hit a building shop and entered the shop. The air bags did not deploy, and I was shaken up but not injured. Thankfully, there was no one at the front desk area of the business. The car was not drivable and was towed to a body shop.
This is the second time this year 2025 my Toyota Highlander 2019 stalled fist in the middle of of intersection and second on the drive thru in in&out. Suddenly my car died. Tried to turn on followed the on screen instructions but the car failed to turn on. The first time it happened in the middle of the intersection while waiting for the light to change, after the issue I when straight to a car shop and oreilly they have this machine to check any possible issues and he said nothing shows in his machine but he think it's the battery but I told the guy my battery and on the car shop Midas same result no major issue found and one of the technicians says It could be the auto shot off features, that must be manually turn off since this will automatically turn on. …
Was stuck in traffic on a highway for about 25 minutes going 0 miles per hour because of an accident about 5 miles away. Then the traffic started to clear and began driving on the road again. About five minutes later, the vehicle lost full drive abilities and the check engine light came on, traction control light on, brake light was on, ABS light was on, stability control warning light on, and then on the info screen the vehicle stated, "Hybrid System Malfunction Stop in a Safe Place, See Owner's Manual", screen then showed within 2-seconds, "Pre-Collision System Malfunction Visit Your Dealer", then in about 2 additional seconds later the info screen stated, "Check Engine Visit Your Dealer", then most every waring light turned on, and there was no power for drive with either hybrid or gasoline engine. …
Since having recall work done my vehicles computer system has not been functioning the same. My vehicle has been stalling out and saying braking power low,stop in a safe place, charging system malfunction. I've reached out to Haley Toyota 8301 Midlothian Turnpike, Richmond, VA 23235 where the diagnostic was done and let them know of the error code I was given ( P0335) Crankshaft Position Sensor "A" Circuit. I took it in for diagnostic there and they told me they couldn't find any issues with my vehicle , ( picked up Oct.3, 2021). It's Oct.4 , 2021 and here I am at Sams Club trying to leave but my vehicle will not start. I contacted Toyota again and let them know of the same issue and they said to once again bring it in for diagnosing. …
What component or system failed or malfunctioned, and is it available for inspection upon request? 12V battery How was your safety or the safety of others put at risk? Vehicle unable to start. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Inspected by independent service center. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning of impending failures. 2/17/2020, vehicle purchased new from Toyota of Morristown (NJ). 2/23/2023, vehicle's (3 year old; 1 week outside of warranty) original OEM 12V battery failed and was replaced with Toyota OEM 12V battery (Part #2880031291) by independent service center ($376.61). …
Complaint Regarding DCM Module Failure in 2019 Toyota Highlander Platinum Our 2019 Toyota Highlander Platinum is experiencing severe audio system malfunctions, beyond simple Bluetooth and connectivity failures. The vehicle sporadically emits an extremely loud screeching feedback sound upon startup and at unpredictable times while driving. This deafening noise is highly distracting to the driver, posing a significant safety risk. Toyota has been aware of this issue for years and documented it in Technical Service Bulletin T-SB-0112-20, which identifies the faulty vehicle assembly locations. However, despite widespread reports from owners and the high cost of repairs, Toyota has failed to issue a recall. Given the clear safety hazards associated with this defect, I firmly believe Toyota should recall affected Highlanders and provide immediate replacements for the defective DCM module. …
Intermittent EXTREMELY LOUD ear-piercing high pitched noise coming from speakers upon starting the vehicle. The volume of the sounds is extremely high, the loudest noise I've ever heard. The sound lasts about 5 seconds. I am concerned for the safety of our hearing, for my family, including our children. It has not been reproduced at the service center because it is intermittent. I have read online where others with the similar year/make/model experienced it and have varying success by re-subscribing to Toyota SOS Safety connect ($80/year), or replacing the Data Communication Module (DCM). If not uner warranty, this costs thousands of dollars. I have tried re-subscribing to the Safety Connect but it does not work, and the dealer wants me to pay additionally for them to see why this safety feature is not working in my car. There is no warning before this loud sound presents.
Electrical complaints in other Highlander years
Frequently asked questions
How common are electrical problems on the 2019 Toyota Highlander?
NHTSA has 56 complaints about the electrical system of the 2019 Toyota Highlander, 11% of the model year's 500 complaints.
Is there a recall for 2019 Toyota Highlander electrical problems?
No. NHTSA lists no electrical system recall for the 2019 Toyota Highlander, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Toyota Highlander electrical problems start?
Half of the complaints with a recorded mileage happened before about 5,000 miles, and 76% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 0 fires and 3 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.