Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Subaru Forester owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2020 Subaru Forester. The contact stated while driving at 60 MPH, a deer jumped in the roadway causing damage to the front driver-side engine compartment. No air bags had deployed. The contact had managed to pull onto the side of the road. The contact stated she and the front passenger exited the vehicle safely when shortly afterward a fire started in the front driver-side engine compartment. No injury was sustained. A police report was filed but was unavailable. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The vehicle was towed to a tow lot where it was then taken by the insurance company. The contact stated the insurance company had the vehicle in their possession for an investigation. The origin of the fire was unknown. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.
I was in a parking lot at the time driving very slowly to pick a spot. When I went to turn right into the spot my car accelerated at an alarming speed. I had not control over it as it kept turning. It hit the car parked in front of my space pushing it and went on to hit the car parked to the right damaging both the front left and right sides of my vehicle and the 2 parked cars before coming to a stop. Fortunately it was 9am and not very crowded, there were no passengers in both vehicles and no one walking in between or by the cars which could have been tragic. I was wearing a seatbelt. The police were called and completed a report. The Subaru dealership was called and Subaru of America was called. The car was inspected by a Bosch.-EAA representative for Subaru on 8/4/2021. I have not heard back from Subaru so far although I was told it could take several weeks. …
At one year old this vehicle was involved in a frontal collision with a deer and immediately upon impact burst into flames. The fire breached the firewall between the engine compartment and passenger compartment within less then a minute. Within 2 minutes the engine compartment and front seat area was completely engulfed in flames and within 3 minutes the entire vehicle was engulfed. It appears the fire started as the fuel shut-off system that is supposed to stop the fuel from flowing once the airbags are deployed failed. This put the occupants of this vehicle and any others had this been a collision with another vehicle in extreme danger of serious injury if not even death. …
The contact owns a 2020 Subaru Forester. The contact stated that the auto START/STOP feature was malfunctioning. The contact stated that upon coming to a complete stop, the engine turned off, but failed to restart after releasing the brake pedal. The message "Engine Disabled" was displayed. The contact depressed the brake pedal and pressed the Push to Start button and was able to continue driving. The contact stated that the failure had been recurring. The dealer was notified of the failure and advised the contact to manually deactivate the auto Start-Stop feature by pressing a button. The contact stated that she followed the dealer's instructions; however, the feature had been engaging independently and the failure had been recurring while at a complete stop. The vehicle was taken to the dealer to be diagnosed. The vehicle was not diagnosed or repaired. …
The contact owns a 2020 Subaru Forester. The contact stated that while his wife was stopped at a red traffic light in the middle lane and surrounded by other vehicles, the auto START/STOP system engaged; however, when the brake pedal was released, the vehicle failed to restart. After several attempts, the vehicle eventually restarted, allowing the driver to safely pull over. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed with a dead battery. The dealer advised the contact about turning off the auto START/STOP system. The battery had been marked as good on two separate occasions. The battery was replaced. The contact reached out to the manufacturer, who opened a case but confirmed there was no warranty coverage on the vehicle. The manufacturer referred the contact to the NHTSA Hotline to report the failure. …
The contact owns a 2020 Subaru Forester. The contact stated while driving approximately 30 MPH, the check engine warning light illuminated. The contact stated that the check engine warning light remained illuminated after starting the vehicle and shifting to drive(D) or reverse(R). The contact stated that the engine temperature gauge indicated that the engine was "COLD" even after she had driven the vehicle approximately 30 minutes. The contact stated that the heater no longer worked as intended and only blew out cold air. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the thermostat coolant valve needed to be replaced. The contact was advised that the part needed for the repair was on a national back order. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 65,000.
The contact owns a 2020 Subaru Forester. The contact stated while driving 35-38 MPH in cold weather, the temperature gauge indicated that the vehicle temperature was cold. The check engine warning light was illuminated. Additionally, the Forward Collision Avoidance system, the Lane Keep Assist, the Auto START/STOP feature, the cruise control mode, and other unknown features no longer operable messages were displayed. Additionally, the vehicle shifted into Sport (S) mode. The contact was able to drive to her residence. The vehicle was taken to the dealer, where it was diagnosed that the thermal control valve needed to be replaced. The contact stated that there was an inch-long slice like cut in the front passenger's seat. The vehicle was not repaired. The manufacturer was notified of the failure via mail. The failure mileage was approximately 47,000.
Daughter was driving vehicle on the morning of September 15, 2023, when smoke came from under hood. Immediately pulled over and engine was engulfed in flames. Got out of vehicle and moved a safe distance away as glass started to break and fire department arrived on scene. Picked up vehicle on September 12, 2023, after having the thermal control valve replaced (warranty) but after doing research there are other components that also had to be replaced (fuel line, etc) as part of this repair. Noticed there have been other vehicles with recall due to thermal control valve just nothing on the Subaru Forester. Completely traumatized as the vehicle was gone in a little over 3 minutes. Have been in contact with Subaru but no resolution on what they believe caused the car to catch on fire. Did authorize them to get "black box" on September 29, 2023.
The contact owns a 2020 Subaru Forester. The contact stated while driving 75 MPH, the Forward Collision Avoidance Automatic Emergency Braking system activated and applied the brakes. The contact was able to pull to the shoulder of the roadway, where he smelled a burnt smell in the interior of the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine and brake warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the throttle body. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 35,600.
The contact owns a 2020 Subaru Forester. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to respond. The vehicle stalled and then went into sleep mode. The contact was able to restart the vehicle after several attempts. There were several unknown warning lights illuminated. The contact stated that the vehicle also experienced failures with the electrical system. The vehicle was taken to the local dealer where the contact was informed that the vehicle was operating as designed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 1,300.
Engine complaints in other Forester years
Frequently asked questions
How common are engine problems on the 2020 Subaru Forester?
NHTSA has 84 complaints about the engine & cooling of the 2020 Subaru Forester, 14% of the model year's 603 complaints.
Is there a recall for 2020 Subaru Forester engine problems?
No. NHTSA lists no engine & cooling recall for the 2020 Subaru Forester. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2020 Subaru Forester engine problems start?
Half of the complaints with a recorded mileage happened before about 37,000 miles, and 33% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 4 fires and 0 injuries to engine & cooling problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.