Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2022 Ram 2500 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2022 Ram 2500. The contact stated that while driving and attempting to park, when the brake pedal was depressed, it became spongy and was inoperable. As a result, the contact crashed into a building and damaged the aluminum siding of the building. The vehicle was taken to the dealer, where it was diagnosed with front left caliber failure and needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 2300.
What component or system failed or malfunctioned, and is it available for inspection upon request? FACTORY TRAILER BRAKE CONTROL UNIT. How was your safety or the safety of others put at risk? BRAKE CONTROL INTERMITTENTLY FAIL TO WORK. NOT ABLE TO STOP 15,000 LB TRAILER. WEIGHT PUSHS VEICHLE OUT OF CONTROL. Has the problem been reproduced or confirmed by a dealer or independent service center? NEVER DOES IT FOR THE DEALER OR INDEPENDENT SERVICE CENTER AND THEY TOW MY TRAILER AROUND SEVERAL TIMES. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? DEALER & SERVICE CENTER Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? …
The contact owns a 2022 Ram 2500. The contact stated that while operating the vehicle, the messages "Auto Park Disabled", "Service Electronic Stability Control", and "Trailer Brake System" were displayed. Additionally, while hauling a camper, the message "Trailer Brakes Disabled" was displayed, and the trailer brakes became inoperable. After restarting the vehicle, the failure was self-corrected, and the trailer brakes operated normally. The vehicle was taken to the local dealer, but the cause of the failures was not yet determined. The manufacturer was not yet contacted. The failure mileage was 65,000.
The contact owns a 2022 Ram 2500. The contact stated while driving at an undisclosed speed, the brake pedal was depressed and traveled to the floorboard. There was no warning illuminated. The contact engaged the parking brakes to stop the vehicle. The vehicle was towed to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired. The contact stated that the failure persisted, and several unknown warning lights were illuminated. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 44,000.
the vehicle has been inspected by an independent engineer from Bosch, supplied by FCA (Fiat Chrysler Automobiles), it indicates that an expert assessment has been conducted. In this case, the following answers can be provided based on that information: 1. Components or systems that failed or malfunctioned: - Half shaft axle front left - Wheel assembly - Brake rotor disc - Suspension - Drive shaft - Transfer case - Right front axle shaft - Right front caliper - Right front caliper bolts 2. Availability for inspection upon request: The availability of the failed components for inspection may depend on the specific arrangements made between the vehicle owner and the independent engineer from Bosch. It is recommended to contact the engineer or FCA for further information regarding inspection availability. 3. …
1. Complete Brake Failure. No warning lights came on. There is no emergency warning system for Brake Failure. This could have been catastrophic. This could have turned deadly if we were driving on the highway with no warnings Dec 15, 2024 I drove the truck during the day on the highway and made various stops for Christmas Shopping. I went for dinner with my Family. After dinner climbed into the truck and depressed the break and started the truck. Once the truck started the break pedal could be pushed to the back floorboards. I know this was not right. Turned the truck off and started it again and up it in drive thinking it would correct. It did not turned onto a sidewalk put he truck in park and called a towtruck. 2. The 12" display goes black constantly. Even after several software upgrades. You cannot see heat/radio/ mapping/ phone system nothing it completely shuts down 3. …
Vehicle would not start. I put a new battery in, the vehicle still would not start, and the break pedal was stiff. Had someone jump the vehicle, i started it and drove to the dealership service department where I originally bought the vehicle. They said it may be the starter. but they hadn't looked at the vehicle. I told them I would drive to a different shop because it's cheaper. When I tried to put it in drive the vehicle would not move it was giving an error message on the dash. I had to leave the truck there. 2 days later they called me and told me the issue was caused by a recalled part and they fixed the issue. When I arrived they told me I would have to pay $215 diagnostic fee. I told them it's federally prohibited to charge for a recalled part. I had to argue with them to get my vehicle back. They told me next time I should tow the vehicle if I dont want to pay a diagnostic fee. …
I had to hard brake on a damp roadway at about 50 mph. The truck began to rotate and skid. I had no control over the vehicle until it stopped. The dash lights came on for a failure of the brakes, abs, traction control, and stability control. All of the lights went off then the truck seemed to drive normally. A short time later the lights came on and would not go off. Took the truck to the dealer. The hydraulic control unit was bad and was replaced. This did not fix the truck. Now it needs an abs control module. The truck remains at the dealer awaiting this repair. This appears to be a problem in the previous model year Ram 2500's and it looks like my 2022 is affected also. There are recalls for these trucks but not for my model year.
My 2022 RAM 2500 only has about 10k miles and today when I started the vehicle in my driveway, the ABS and Traction control lights came ON. Did some google searching and found that this is a known issues plaguing RAM trucks since 2018! I'm going to call dealer tomorrow and hopefully this can be diagnosed and fixed promptly. However I'm not confident as I'm still waiting on a different RAM recall which dealer says the parts are only being released to each dealer in quantities of 1 per month. Paying $80k+ for a truck that can't be driven due to known manufacturers issues from 6 yrs ago is unacceptable. I hope NHTSA can help force RAM to address these issues.
The contact owns 2022 Ram 2500. The contact received notification of NHTSA Campaign Number: 22V140000 (Service Brakes, Hydraulic, Electronic Stability Control), 22V835000 (Power Train), 22V904000 (Structure), and 23V060000 (Electrical System) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The contacted both recalls were completed on June 13th, 2023, but feels the length of time to repair the recall was excessive.
Related recalls
Service brakes, air › Antilock › Control unit/module
Chrysler (FCA US, LLC) is recalling certain 2022 Dodge Durango and Ram 2500 and 3500 vehicles. Due to a software malfunction, the ABS control module may disable the electronic stability control system.
Remedy: Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed beginning July 11, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403.
Brake complaints in other 2500 years
Frequently asked questions
How common are brake problems on the 2022 Ram 2500?
NHTSA has 22 complaints about the brakes of the 2022 Ram 2500, 12% of the model year's 181 complaints.
Is there a recall for 2022 Ram 2500 brake problems?
Yes — NHTSA recall 24V-415 (control unit/module, Jun 6, 2024). Recall repairs are free at authorized dealers.
At what mileage do 2022 Ram 2500 brake problems start?
Half of the complaints with a recorded mileage happened before about 44,000 miles, and 33% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 0 fires and 0 injuries to brakes problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.