Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2016 Ram 1500 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2016 Ram 1500. The contact stated that while driving 55-60 MPH, the ABS warning light was illuminated, and the contact decelerated to 40 MPH and drove a mile. The contact stated that the passenger's side front end made an abnormal sound and collapsed, and the contact was able to coast to the side of the road. The contact then noticed that the front passenger's side tire had detached, the brake lines were leaking, and the front axle was fractured. And there was fire underneath the passenger's side front end of the vehicle. The fire was extinguished by the fire department. It was unknown whether a fire department report was filed. The police officers arrived at the scene, but it was unknown whether a report was filed. …
The contact's girlfriend owns a 2016 Ram 1500. The contact stated while test-driving the vehicle, he noticed the vehicle began to shake. The contact stated no warning light was illuminated. The owner continued to purchase the vehicle. The contact took the vehicle to a tire shop and had both rear tires replaced. The contact continued to experience the failure. The contact stated he replaced the two rear shocks, the two rear rotors, and the rear springs on his own. The contact continued to experience the failure. The contact took the vehicle back to the tire shop and had the rear tires rotated to the front. The contact stated that he continued to experience the failure The contact took the vehicle to another tire shop and exchanged all four tires and rims. The contact continued to experience the failure. …
The contact owns a 2016 Ram 1500. The contact stated while driving 55 MPH, the vehicle was vibrating. There was an abnormal buzzing noise detected. There were no warning lights illuminated. The contact then received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 71,000. VIN tool confirms parts not available.
My truck is equipped with an air suspension system. During winter weather when temperatures dropped in the low 20's and lower, the air system blows a fuse and drops the suspension to an unsafe position for driving. It has occurred several times including while driving. A warning message sometimes (but not always) a warning is flashed on the screen to have the truck serviced immediately. I have had to cancel important trips to the hospital for my disabled wife because the truck is not reliable during Wisconsin winter weather. My local dealer has inspected and assessed he problem. He has given me an estimate to replace the system but cannot assure me that it will not fail. I called RAM customer service to get a technical explanation of the air suspension problem and solution from the manufacturer who designed and manufactured the product. I called RAM customer service seeking an answer. …
I bought this vehicle used and have had nothing but issues with the factory OEM Air Ride Suspension. Driving down any road, it will dump the air in the rear completely, sometimes it will dump the air on just the drivers side front and rear. I get dash warnings saying the air suspension is overheating and needs to cool. The local Dodge Dealer where I bought it knows about the problem and only advised me to replace it with aftermarket suspension. I bought an extended warranty and I personally believe they didn't want to warranty the suspension. It will cost me $4-5k to replace with an air delete kit and could be $5-10k for OEM parts depending on what all gets replaced. Now my warranty is expired and it's all on me. This is a safety problem and is a serious issue as there's thousands of these vehicles with this suspension system having issues. …
I purchased my vehicle 2 months ago and no problems were reported to me. After a few weeks my driver side air bags on my suspension do not inflate. Motor is making sounds and inflating passenger side, but not driver side. Parked truck with the following warning lights on dash (service air suspension & immediate air suspension service/repair required) began contacting dealers with no response back. Even called where it was purchased with no response back either. I was able to get in contact with a dealership and they reported the following: Air suspension compressor /valve block binds/sticks. My vehicle is the main transport for my family and the air suspension deflating while driving is a safety hazard and can cause serious damage if an accident is to occur.
Factory 4 corner air suspension empties and truck lowers when cold. The suspension will drop in cold temps while driving. This then cause a very hard drive that is hard to control especially in snow. Truck suspension was fixed 6 months ago to the best of the dealerships ability. The suspension has dropped 3 times this December during snow storms and almost caused me to ditch the truck and loose control. Dealership is giving me the run around. This is not an uncommon issue the the air suspension according to different dodge forums on the internet. Their is something wrong with entire air system including the electrical system that controls the suspension. So the system could be in normal range but it is actually lowered to the ground.
I was driving on a blacktop road doing 60mph when I topped a hill and suddenly the road surface changed to mud and deep puddle of water , as I hit my brakes all the ABS BRAKE AND ANTI SKID LIGHTS on my dash lite up and the tires locked up and i slide almost sideways into a massive puddle of water at a very dangerous angle. The force of it was very difficult to steer my truck back straight to miss the bridge rails that was just yards ahead. Now the dodge dealership tells me the ABS BRAKE CONTROL MUDULE is under engineering review and can't be replaced because it's on back order. So for my safety I've parked it and bought a chevy . Will sell dodge when fixed if part recalled to make dodge fix it please.
The component that failed was the air ride suspension. When outside air temperature drooped to 0 then the air ride suspension lowered to the bottom and would not inflate. With this the wheels are out of alignment, tires scrape on fenders when turning and there is no suspension, spring action. I had the truck taken to the Ram repair center, they reset the computer and kept the truck in a warm shop until suspension continued to work. The following week when outside air temperature dropped to 0 the same thing happened. Every year truck suspension goes out. No warning. Where I live the outside air temperature below 0 is common in the winter and can last over a week at a time.
The below issue is my 2016's problem, only thing is my truck has a build date of 5/2016. I've replaced this two times already, "it's very expensive" to which I now have a fractured one yet again. I NEED A PERMANENT FIX FOR THIS ISSUE PLEASE. It's my daily driver, hwy driven. ********Below recall noted******** ***16V-301 / S32 Recall Summary The front axle half shafts may fracture and separate from the vehicle. Dealers will replace both front half shafts free of charge to resolve the concern. Chrysler (FCA US LLC) is recalling certain 2016 RAM 1500 trucks manufactured February 19, 2016, to March 3, 2016.
Suspension complaints in other 1500 years
Frequently asked questions
How common are suspension problems on the 2016 Ram 1500?
NHTSA has 68 complaints about the suspension of the 2016 Ram 1500, 4% of the model year's 1,554 complaints. The component named most often is front › springs › air suspension system (1 mentions).
Is there a recall for 2016 Ram 1500 suspension problems?
No. NHTSA lists no suspension recall for the 2016 Ram 1500, though it has 16 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2016 Ram 1500 suspension problems start?
Half of the complaints with a recorded mileage happened before about 53,000 miles, and 27% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 1 fire and 1 injury to suspension problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.