Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2010 Mini Cooper owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2010 Mini Cooper S Hartop. The contact stated that while driving at 25 MPH with the two sunroofs open, the vehicle caught fire. There were flames underneath the rear of the vehicle. There were no warning lights illuminated. The contact opened the hood and threw baking soda on the flames but sustained burns to her hands and face, and medical attention was provided. The neighbors had used a fire extinguisher to put out the fire. The fire department was able to extinguish the fire. The airbags did not deploy. A police report was filed. There was no crash. The vehicle was previously taken to an independent mechanic who replaced the footwell control module. The vehicle was towed to a tow lot. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. …
The contact owned a 2010 Mini Cooper. The contact stated that while driving at an undisclosed speed, he smelled a burning odor within the interior of the vehicle. The contact was able to pull to the shoulder of the road, and after visual inspection, he observed flames emanating from the footwell control module. The contact stated that bystanders assisted him in extinguishing the flames. No police or fire reports were filed. No warning lights were illuminated on the instrument panel. The vehicle was not taken to the dealer or an independent mechanic; instead, it was towed to the contact's residence, where it remains. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number 23V337000 (Electrical System), and the VIN was included. The manufacturer was not notified of the failure. The failure mileage was 78,000.
The contact owns a 2010 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 65 MPH, the vehicle stalled. The contact stated that she was unable to check for warning lights due to a previous failure of the instrument cluster. The contact was able to coast the vehicle over to the side of the road. The contact was unable to restart the vehicle and had the vehicle towed to the residence. The contact stated that the stall was an intermittent failure and occurred at various speeds. …
The contact's son owns a 2010 Mini Cooper Hardtop. The contact stated that the windows failed to roll down, and the turn signals and the headlights were inoperable. Additionally, the check engine warning light was illuminated. The vehicle was taken to several independent mechanics, where it was diagnosed that the footwell control module (FRM) was severely corroded. The contact later received NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The manufacturer was notified of the failure and advised the contact to take the vehicle to the dealer for a temporary repair and she would later receive reimbursement. …
The contact owns a 2010 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the vehicle was experiencing an electrical failure. The contact stated that the turn signals, the headlights, the power window switches, the gauges and other unknown components were inoperable. Additionally, the contact stated that the vehicle had locked independently. The local dealer was contacted and informed the contact that they needed to pay a fee for the repairs. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 93,000. …
On Thursday I was driving my 2010 Mini Cooper S with 75,000 miles on it and there was a total and sudden power outage on the high way. I was able to get to the breakdown lane and had it towed. My mini certified garage ran the computer on it and the car started right up. It was due for an inspection so we did an oil and filter and put on some new tires. No issues were found and car was running well. We picked it up on Friday and Saturday morning after a short drive I was parking and smoke started pouring out from behind the steering wheel. I ran inside a coffee shop for help and they asked if there were flames. I went back out and opened the car door and there was loud noise and the hood was in flames. The entire dash was melted, the hood had a hole burned in it and with the fire rescue interventions the car was a total loss. No one was injured.
The contact owns a 2010 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the power window switch had failed to operate as needed intermittently. Additionally, the contact stated that the gauges were inoperable. An unknown dealer was contacted and advised the contact to tow the vehicle to their location for a diagnostic test. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 123,000. VIN tool confirms parts not available.
My 2010 Mini Cooper convertible recently had an electrical failure. I lost power while driving and the power steering wouldn't work. Once it started again the blinkers wouldn't work and brake lights and radio worked intermittently. I took it to the mechanic and the diagnostic determined that the footwell module is bad. Unfortunately this part is apparently on back order so the part cannot be ordered. The car is not safe to drive nor is a solution available. I looked up recalls on Mini coopers. This current recall shows that the footwell module has been recalled on 2010 hardtop Mini Coopers: MINI Recall 23V-xxx: Footwell Module Attachments: BMW AG is conducting a Voluntary Safety Recall (effective May 11, 2023) on certain Model Year 2007 - 2014 MINI vehicles that were produced between November 16, 2006, and June 27, 2014. …
The FRM module on my 2010 MINI Cooper S failed in 2022. I was unable to access multiple functions on the vehicle, including interior and exterior lighting, window controls, and other operations that worked randomly during this time. I needed my car fully operational for work commuting so I had to find a replacement FRM, which I did from an OEM MINI parts website, [redacted] . The new FRM I purchased was matched to my vehicle's VIN and installed and programmed by my local MINI shop, Detroit Tuned [redacted] ) , in Clawson, MI. The total bill for this was over $800 (I have receipts for the purchase and the install). The recall notice from MINI/BMW came in 2023, and according to their website there is still no fix, which makes no sense since I bought an OEM replacement that was fitted to my car in 2022, as I noted here. …
The dealer refused to perform the required FRM recall inspection and denied the recall without providing any of the federally required documentation. I was forced to pay out of pocket for the FRM module replacement even though my VIN is listed under the safety recall. MINI of Murray stated my FRM "failed," but admitted they never opened the module, which is required to determine internal moisture intrusion. The Service Manager stated they based their denial on "carpet and headliner moisture," which is not part of the FRM recall inspection procedure. I requested the FRM inspection report, photos, and the MINI Corporate denial code. I received none of these. MINI Corporate Recall Team confirmed they had no documentation from the dealer and incorrectly stated that the module does not need to be opened. …
Related recalls
Electrical system
BMW of North America, LLC (BMW) is recalling certain 2008-2014 MINI Clubman Cooper, Clubman Cooper S, Clubman John Cooper Works, and 2007-2013 MINI Hardtop 2-Door Cooper, Cooper S, and John Cooper Works vehicles sold, or ever registered, in Alaska, Colorado, Connecticut, Delaware, Illinois, Indiana, Iowa, Kansas, Kentucky,…
Remedy: Dealers will inspect the sunroof drains, interior footwell area, and FRM and, depending upon the results of the inspection, certain components will be replaced. Owner notification letters were mailed May 13, 2024.
Electrical complaints in other Cooper years
Frequently asked questions
How common are electrical problems on the 2010 Mini Cooper?
NHTSA has 29 complaints about the electrical system of the 2010 Mini Cooper, 32% of the model year's 92 complaints.
Is there a recall for 2010 Mini Cooper electrical problems?
Yes — NHTSA recall 23V-337 (electrical system, May 11, 2023). Recall repairs are free at authorized dealers.
At what mileage do 2010 Mini Cooper electrical problems start?
Half of the complaints with a recorded mileage happened before about 66,000 miles.
Is it dangerous?
Owners linked 0 crashes, 4 fires and 3 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.