Which parts fail
Components named in complaints (service brakes, ABS, rotors and pads, parking brake).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2008 Kia Sportage owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2008 Kia Sportage. The contact stated that while the vehicle was parked and unattended, the vehicle caught fire. The ABS warning light was illuminated before the failure. The fire department extinguished the fire. There were no reported injuries. A police report was filed under case number 22027268. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 112,000.
The contact owns a 2008 Kia Sportage. The contact stated that while driving at undisclosed speeds, the brakes locked up. The contact removed the fuses. The contact called the local dealer, but the vehicle was not diagnosed or repaired. While his daughter was driving, an abnormal dinging sound was detected. The contact changed the calipers and noticed that the ABS box was stuck. The brake warning light was illuminated. The contact put the fuse back in the vehicle. Additionally, the vehicle was leaking brake fluid. The vehicle was taken to the local dealer, who stated that the brake pedal was soft and not to drive the vehicle. The dealer informed the contact that the parts were not available. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 22V800000 (Service Brakes, Hydraulic). The manufacturer was not contacted. …
The contact owns a 2008 Kia Sportage. The contact stated that after driving at approximately 15 MPH, the vehicle was shifted into reverse and the accelerator pedal was depressed; however, the vehicle failed to respond. The contact shifted the gear shifter several times and then drove for a short distance before the vehicle stalled. The check engine warning light was illuminated; the vehicle was able to be restarted. The vehicle was towed to an independent mechanic to be diagnosed. The contact stated that the ABS Hydraulic Control Unit needed to be replaced. The vehicle was not repaired. The vehicle was then taken to a dealer where the vehicle was diagnosed and determined that the ABS Hydraulic Control Unit needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 140,000.
The contact owned a 2008 Kia Sportage. The contact stated while driving 40-45 MPH, the check engine warning light illuminated, and the vehicle was shuddering. Additionally, the contact stated while driving on another occasion, the vehicle experienced brake failure, which nearly led to a crash. An unknown dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact decided to total the vehicle. The vehicle was totaled. The failure mileage was approximately 117,000.
Smoke was pouring out from the passenger front side of the motor compartment. The fuses for the ABS (I think) were taken out so it would stop. I was a told a control module could have something to do with it.
The contact owns a 2008 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V800000 (Service Brakes, Hydraulics); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer and the contact was informed that the vehicle needed to remain in dealer possession since the vehicle failed a safety test related to the recall. After several failed attempts to reach the dealer, the contact was informed that the part needed to repair the recall was discontinued and that she could pick up the vehicle. The manufacturer was notified, and a case was filed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. The vehicle remained in the possession of the dealer. The failure mileage was unavailable. Parts distribution disconnect.
The contact owns a 2008 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V800000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
My sister in law's 08 Kia Sportage ex had all the dash warning lights come on, the code showed p0501 wheel speed sensor malfunction. I replaced rt frt sensor and still same code. Took it to local shop and they said something is shorted because they can't read all the lights on. I checked some fuses but found none blown. It seemed like the brakes were a little weak and I drove it for a test and noticed it was pulling hard to the right, then it started to pulse as if the ABS was stuck on. I turned for home and parked it. Next day went to try it again and it was dead, I charged battery, the door locks were clicking on/off and horn blowing. I unhooked battery terminals to charge battery and when it was fully charged I hooked it up and the ABS module on front passenger side of car was running and getting hot. …
Kia is ripping people off to the tune of $1,700 to $1,800 for their faulty ABS brake controllers plus labor. It is a widely know problem that brake fluid seeps out of the back of this unit onto the circuit board and causes a variety of safety and mechanical issues. A year and a half ago I experienced a problem with the ESC traction light coming on, followed by a flashing 4x4 light and then finally a check engine light. The worst part about this is that it then slams itself into first gear going down the road! Yes, you heard that correctly. This can happen very quickly. Kia, you have a safety issue! I replaced the unit with a used one for $350 plus installation and now it has the same problem a year and a half later. There were two possible controller units for the 2008 Sportage and they look identical but are not interchangeable. …
I was in the car, parked in a wendys parking lot, engine off, radio on. There was a loud pop followed by smoke, a gentleman in a truck 3 spaces away heard it and saw it. We got out to look at it and the smoke was increasing, I opened the hood and you could see flames about 2 inches high around the box mounted inside the engine compartment, on the passenger side up near the headlights and over the wheel well. We shut it and waited for the fire department, everything inside the engine compartment that could melt did melt, all the paint on the hood etc, passenger door will not open or shut without noise and an extra push or pull. I am not a mechanic but I am pretty sure that the little black box was the ABS controller. Just lucky that I wasn't driving on the highway. I have seen that there are several other complaints about the same thing.
Related recalls
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Kia America, Inc. (Kia) is recalling certain 2008-2009 Sportage vehicles previously recalled under recall 16V-815. An engine compartment fire originating from around the Hydraulic Electronic Control Unit (HECU) may occur while parked or driving.
Remedy: Owners are advised to park outside and away from structures and other vehicles until the recall repair has been performed. Dealers will inspect and replace the HECU, its wiring harness, and its fuses, as necessary, free…
NHTSA investigations
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando.
Brake complaints in other Sportage years
Frequently asked questions
How common are brake problems on the 2008 Kia Sportage?
NHTSA has 23 complaints about the brakes of the 2008 Kia Sportage, 23% of the model year's 98 complaints. The component named most often is antilock › abs warning light (1 mentions).
Is there a recall for 2008 Kia Sportage brake problems?
Yes — NHTSA recall 22V-800 (control unit/module, Oct 24, 2022). Recall repairs are free at authorized dealers.
At what mileage do 2008 Kia Sportage brake problems start?
Half of the complaints with a recorded mileage happened before about 93,000 miles, and 6% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 4 fires and 0 injuries to brakes problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.