Most common 2002 Kia Optima problems
Share of the 107 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Kia Optima complaints by model year
Best Optima years: 2010, 2009, 2008. Years to avoid: 2013, 2015, 2012, 2016, 2011. Compare all years →
2002 Kia Optima recalls (3)
Suspension › Front
Kia motors corporation (kmc) is recalling 36,538 model year 2001-2004 optima vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island,…
Remedy: Kmc will notify owners and dealers will repair the vehicles free of charge. The safety recall began on June 15, 2009. Owners May contact Kia's consumer assistance center at 1-800-333-4542.
Fuel system, gasoline › Storage › Tank assembly
Some passenger vehicles May contain a fuel tank assembly valve that May not close properly. If a vehicle with a fuel tank assembly valve that is not properly closed were to roll over, fuel spillage May occur.
Remedy: Dealers will install an additional fuel tank assembly valve. Owner notification began June 25, 2004. Owners should contact Kia at 1-800-333-4542.
Electrical system › Starter assembly
On certain passenger vehicles equipped with 2.5 and 2.7 liter v6 engines, the crankshaft position sensor (ckp) cases did not meet dimensional specifications.
Remedy: Dealers will replace the ckp. Owner notification began March 28, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time…
What 2002 Kia Optima owners say
Body & structure all 30 →
The contact owns a 2002 Kia Optima. The contact stated that after he replaced all four tires, the vehicle was taken to an independent mechanic for an alignment; however, the mechanic was unable to perform an alignment due to the subframe corrosion. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 09V183000 (Suspension) however, the VIN was not included in the recall. The failure mileage was approximately 111,000.
locked the car as most people do, then went to unlock the car heard it unlock but the door would not open. I could hear the door sound like it was locking/unlocking like it was stuck. I tried to climb through the passenger side to open the door from the inside and it will not open. The door appears to be "unlocked" but it is not and will not open creating a hazard if in an accident there is no way to get to safety. In researching online this is a common problem and there is a part in the lock mechanism that gets stuck so the door does not unlock and cannot open. It appears it has been reported several times on the year of my car and other years but nothing has been done. There is no warning that this will happen, you just lock the doors and then it doesn't unlock.
Suspension all 21 →
The contact owns a 2002 Kia Optima. The contact stated that after he replaced all four tires, the vehicle was taken to an independent mechanic for an alignment; however, the mechanic was unable to perform an alignment due to the subframe corrosion. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 09V183000 (Suspension) however, the VIN was not included in the recall. The failure mileage was approximately 111,000.
I just got my 2002 Kia Optima and it just recently started having issues. I was driving down the road and my car started to slightly wander to the left, I thought OK.. It needs an alignment. So then it started jerking to the right, so bad I got pulled off to the side of the road and couldn't control it. I parked my car in a parking lot til my bf could come look at it, and I had him drive it home and the same thing happened to him. He looked at every possibility at what it could be as he is a mechanic and said lower control arm. It has been sitting in my yard for a week. It is not safe to drive. …
Air bags
Tl* the contact owned a 2002 Kia Optima. While driving at an unknown speed, the vehicle hydroplaned and crashed into a tree. The air bags failed to deploy. There were no injuries and a police report was filed. The vehicle was destroyed and towed. The dealer was not contacted and the manufacturer was not notified of the failure. The approximate failure mileage was 219,000.
Purchased car brand new on April 30, 2003 - incident #1: July 15, 2003, I was traveling about 30-35 miles per hour exiting the mass pike exit at route 30. All traffic was slowing to exit - I applied the brakes - went all the way down - realized that the breaks were not working - panicked - impacted the vehicle in front of me. The airbags did not work. Incident #2: August 8, 2003, when vehicle was repaired the owner of bucci's auto body took the car in the parking lot for a test drive. At about 15 miles per hour - when brakes were applied the front freezed up and the back pushed forward to create a lunge forward effect. I contacted Kia motor America in irvine, ca and have a complaint file number. …
2002 Kia Optima engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.4L 4-cyl | 5-speed manual | FWD | 19 / 26 / 21 |
| 2.4L 4-cyl | 4-speed automatic | FWD | 18 / 24 / 20 |
| 2.7L 6-cyl | 5-speed manual | FWD | 17 / 23 / 19 |
| 2.7L 6-cyl | 4-speed automatic | FWD | 16 / 22 / 18 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2002 Kia Optima a good car?
Based on 107 owner complaints filed with NHTSA, the 2002 Optima rates better than average: 50% fewer complaints than a typical year of the Optima at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2002 Kia Optima?
The body & structure — 30 complaints, 28% of all complaints for this model year, most often about frame and members. Next are the suspension (21) and air bags (19).
How many recalls does the 2002 Kia Optima have?
There are 3 recalls for the 2002 Kia Optima, the most recent from May 27, 2009 (front). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Kia Optima?
The best years by complaints, compared at the same age, are 2010, 2009 and 2008. Years to avoid or approach with caution: 2013, 2015, 2012, 2016 and 2011. See the full Kia Optima years comparison.
At what mileage do 2002 Kia Optima problems happen?
The median mileage reported in complaints is about 85,000 miles; 25% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.