Most common 2016 Hyundai Sonata Plug-In Hybrid problems
Share of the 26 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Sonata Plug-In Hybrid complaints by model year
Best Sonata Plug-In Hybrid years: 2019. Compare all years →
2016 Hyundai Sonata Plug-In Hybrid recalls (2)
Electrical system › Software
Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of…
Remedy: Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.
Hybrid propulsion system
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Hyundai Sonata Plug-In Hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently.
Remedy: Hyundai will notify owners, and dealers will remove the VPD switch and install a new Battery Management System (BMS) that contains an Overvoltage Protection Device (OPD). The recall is expected to begin May 2018.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2016 Hyundai Sonata Plug-In Hybrid:
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
What 2016 Hyundai Sonata Plug-In Hybrid owners say
Engine & cooling
The contact owns a 2016 Hyundai Sonata Plug-In Hybrid. The contact stated that on three separate occasions while driving approximately 65 MPH, the "Check Hybrid System - Turn Off Engine" message was displayed. The check engine warning light illuminated. The contact then stated that the vehicle decelerated and went into LIMP Mode. The vehicle was towed to the dealer however, the failure could not be duplicated. The contact stated that the failure recurred. The vehicle was taken back to the dealer but the failure could not be duplicated; however, the contact stated that he provided diagnostic test data to the technician that displayed error codes however, the failure could not duplicated. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 65,000.
The contact owns a 2016 Hyundai Sonata Plug-In Hybrid. The contact stated while driving 70 MPH or faster in Hybrid Mode, the vehicle stalled. The HEV error warning light was displayed on the instrument panel. The check engine warning light was also illuminated. The contact turned off the vehicle and disengaged the HEV Mode for the vehicle to restart and function as intended. The failure occurred three times. The vehicle had been taken to the dealer however, the mechanics were unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 66,000.
Electrical system
My 2016 plug in hybrid Sonata repeatedly inidcates that there is "high system temperature switching to hybrid mode." This first happened on my first long trip in the car in 10/21 and has happened repeatedly since. This happens at all temperatures, including moderate temperatures (mid 70s). It seems to happen randomly, such as when battery has several miles of charge left in it, when it is fully discharged, and repeatedly when the car is already running in hybrid mode, which a driver could interpret means that the engine is about to shut down, as I did on a long trip. I have taken it to two separate dealers, and the only thing they did was replace the fuel pump, which did not solve the problem. In addition, the battery life has reduced greatly, despite the fact that I always fully discharge and recharge the batter. …
While driving the car getting error message on dashboard "Check Hybrid System Turn Off Engine", The Gas engine turn off and switch to continue on electric till able to pull on the side of the road. Turn Off engine, wait a min. Start car again and working fine. This issue appears randomly many times in the last two years while driving. Car was at dealer shop multiple times with no repair, was told we don't see active error message or they can't re-create the error. however scan show P261F error. Open Ticket with Hyundai #21018148 while car at the dealers for weeks at the time. each time told check engine got back on but not the message they are looking for.
Fuel & propulsion system
The contact owns a 2016 Hyundai Sonata Plug-In Hybrid. The contact stated that on three separate occasions while driving approximately 65 MPH, the "Check Hybrid System - Turn Off Engine" message was displayed. The check engine warning light illuminated. The contact then stated that the vehicle decelerated and went into LIMP Mode. The vehicle was towed to the dealer however, the failure could not be duplicated. The contact stated that the failure recurred. The vehicle was taken back to the dealer but the failure could not be duplicated; however, the contact stated that he provided diagnostic test data to the technician that displayed error codes however, the failure could not duplicated. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 65,000.
The contact owns a 2016 Hyundai Sonata Plug-In Hybrid. The contact stated while driving 70 MPH or faster in Hybrid Mode, the vehicle stalled. The HEV error warning light was displayed on the instrument panel. The check engine warning light was also illuminated. The contact turned off the vehicle and disengaged the HEV Mode for the vehicle to restart and function as intended. The failure occurred three times. The vehicle had been taken to the dealer however, the mechanics were unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 66,000.
2016 Hyundai Sonata Plug-In Hybrid engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.0L 4-cyl plug-in hybrid | 6-speed dual-clutch | FWD | 38 / 41 / 40 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2016 Hyundai Sonata Plug-In Hybrid a good car?
There isn't enough complaint history for the Sonata Plug-In Hybrid to compare model years reliably. So far owners have filed 26 complaints with NHTSA.
What is the most common problem with the 2016 Hyundai Sonata Plug-In Hybrid?
The engine & cooling — 18 complaints, 69% of all complaints for this model year. Next are the electrical system (12) and fuel & propulsion system (5).
How many recalls does the 2016 Hyundai Sonata Plug-In Hybrid have?
There are 2 recalls for the 2016 Hyundai Sonata Plug-In Hybrid, the most recent from September 24, 2021 (software). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Sonata Plug-In Hybrid?
The best years by complaints, compared at the same age, are 2019. See the full Hyundai Sonata Plug-In Hybrid years comparison.
At what mileage do 2016 Hyundai Sonata Plug-In Hybrid problems happen?
The median mileage reported in complaints is about 30,000 miles; 85% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.